Professional Documents
Culture Documents
08120 - Aluminium Frames
08120 - Aluminium Frames
08120
ALUMINIUM FRAMES
Contents
PART 1 GENERAL........................................................................................................................2
1.1 DESCRIPTION OF WORK ...........................................................................................2
1.2 QUALITY CONTROL...................................................................................................2
1.3 SUBMITTALS ...............................................................................................................2
PART 2 PRODUCTS .....................................................................................................................2
2.1 MATERIALS..................................................................................................................2
PART 3 EXECUTION ...................................................................................................................2
3.1 PREPARATION .............................................................................................................2
3.2 INSTALLATION/APPLICATION/PERFORMANCE/ERECTION ............................2
PART 1 GENERAL
A. General
1. Frames.
2. Sidelights.
3. Transoms.
4. Borrow lights.
1. Glass, glazing and sealants of the units shall be part of the work included in this
Section and shall be as specified in Section 08800, GLASS AND GLAZlNG.
2. Hardware other than door manufacturer's products identified herein is specified
in Section 08710 FINISH HARDWARE.
C. The supplying of fastenings, all connections to the building structure and other items not
mentioned specifically herein, but which are necessary to make a complete installation
shall also be included.
A. Standards
The publications listed below form a part of this Specification to the extent referenced.
The publications are referred to in the text by basic designation only.
1.3 SUBMITTALS
PART 2 PRODUCTS
2.1 MATERIALS
A. Manufacturer.
1. Frames include all transoms, sidelights, borrow lights and view windows as
shown on the Drawings.
2. Frames shall be custom aluminium extrusions with 3.0 mm minimum wall
thickness, of profiles shown on the Drawings.
3. All breaks, angles and arrises shall be uniform, straight, sharply defined and true.
Corners shall be mitered, accurately fitted, welded, properly finished with
smooth, rigid, invisible joints.
4. Jamb anchors shall be manufacturer's standard type to suit wall construction. A
bent steel plate adjustable clip bolted to frames and of a material as specified for
jambs on-the-floor-construction shall be extended for proper anchorage at bottom
of jambs and secured with 10 x 50 mm expansion bolts or shot-in studs.
5. All frames shall be provided with temporary spreader channel at bottom.
6. Frame reinforcement shall be aluminium as follows:
a. Provide 10 mm minimum hinge reinforcement at each hinge location as
detailed herein.
C. Hardware shall be installed under this Section and, except as specified herein, shall be
furnished as shown on drawings.
D. Finish.
E. Coal tar epoxy coating shall be submitted for the Company’s approval.
PART 3 EXECUTION
3.1 PREPARATION
B. Paint aluminium surfaces in contact with lime mortar or concrete with an alkali-resistant
coating.
3.2 INSTALLATION/APPLICATION/PERFORMANCE/ERECTION
B. Installation shall be carried out by a specialist who has performed the same Aluminium
Frame installation for at least 10 years, and is approved by the manufacturer and the
Engineer.