Professional Documents
Culture Documents
FW: Remaining Tie Ins Isolation Required.: Abdulrehman Kayamuddin
FW: Remaining Tie Ins Isolation Required.: Abdulrehman Kayamuddin
Inbox
Good morning!
Please see below mail received from your office regarding the subject, I would like
to request you to let me know about any work permit is pending with SEC and
that is affecting your schedule.
Regards,
Abdulrehman Kayamuddin
KTS, Site Manager, Tabuk
Regards,
Naeem Dad Khan
Project Manager
Maintenance Engineering Department
Marine Services Co. Ltd.
Cell# 00966556154695
Email: naeemdad@mscl-marser.com
https://outlook.office.com/owa/projection.aspx 1/4
4/8/2019 FW: Remaining Tie Ins Isolation Required.
Cc: Naeem Dad Khan, Arshad Qamar, Abo Bakkar Siddik, Sadique Ahsan, Wagiealla Saleh
Reply all | Delete Junk |
Dear Gents,
Kindly chage the subject of this mail to Tie- in schedule in stead of ball valve shortage.
Regards
Saeed Ahmad Janjua
*Tie-in for new Crude Separator Feed&Return header/line to By-Pass Tank 12. ( C O M P L E T E
D ).
Valves Nos; #120, #121, #175, #176, #343, & #344 should be remains close. SEC can open Valves
Nos; #168, #169, #170, #164, #165 & #148 and SEC can run the Separator Skid “E” as well.
*Tie-in for COTP Feed&Return Piping from Crude Feed Header before valve# 229/228.
Best regards,
Conrado
We would like to request Tie-in for the Following Areas: (4 days Tie-in Request)
*Tie-in for new Crude Separator Feed&Return header/line to By-Pass Tank 12.
Valve No. 175 & 176 for close temporarily. Valve No. 120 & 121 for close temporarily. Valve No. 168 &
169 for close temporarily. Valve No. 164 & 167 for close temporarily. Valve No. 148 for close temporarily.
https://outlook.office.com/owa/projection.aspx 2/4
4/8/2019 FW: Remaining Tie Ins Isolation Required.
Fuel Oil Separator Skid “E” isolation valve for return to be close temporarily. Install new Valves (#344 /
Reply
#343) andallhas
|to be Delete
close Junk |
and install blind.
spectacle
*Tie-in for new Crude Separator Feed&Return header/line to By-Pass Tank 14.
Valve No. 229 & 228 for close temporarily. Valve No. 210 & 209 for close temporarily. Valve No. 219 &
218 for close temporarily. Valve No. 164 & 167 for close temporarily. Install new Valves (#354 / #353)
and has to be close and install spectacle blind.
*Tie-in for COTP Feed&Return Piping from Crude Feed Header before valve# 229/228.
Regards,
Conrado
Thank you very much for updated schedule and well coordinated efforts made possible to accomplish
planned task with in the provided shutdown periods.
Get Outlook for Android
We just received 7 Nos. Ball Valves, and please see attached updated tie-in as of March 27, 2019.
Best regards,
Conrado
<Workshop@mscl-marser.com>
Reply Re:
Subject: all | Delete
Ball Valves Junk |
shortage
Arshad Qamar
Dear gents,
Very Important
Kindly provide us the delivery status of the abovementioned valves since it is badly affecting out tie in
schedule of priority units(16,17,14&15).Also please send me the overall updated tie in schedule to focus
on the balance ones.
Regards,
Mohamed Ali
Need assistance or you didn't receive a reply? Kindly send your message to info@kafougroup.com . E-
mails can involve SUBSTANTIAL RISKS, e.g. lack of confidentiality, potential manipulation of contents
and/or sender's address, incorrect recipient (misdirection), viruses etc. Based on previous e-mail
correspondence with you and/or an agreement reached with you, Kafou Holding Co. or any of its
subsidiaries considers itself authorized to contact you via e-mail. Kafou Holding Co. or any of its
subsidiaries assumes no responsibility for any loss or damage resulting from the use of e-mails. The
recipient is aware of and accepts the inherent risks of using e-mails, in particular the risk that the
business relationship and confidential information relating thereto are disclosed to third parties. Kafou
Holding Co. or any of its subsidiaries reserves the right to retain and monitor all messages. Messages
are protected and accessed only in legally justified cases.
Need assistance or you didn't receive a reply? Kindly send your message to info@kafougroup.com . E-
mails can involve SUBSTANTIAL RISKS, e.g. lack of confidentiality, potential manipulation of contents
and/or sender's address, incorrect recipient (misdirection), viruses etc. Based on previous e-mail
correspondence with you and/or an agreement reached with you, Kafou Holding Co. or any of its
subsidiaries considers itself authorized to contact you via e-mail. Kafou Holding Co. or any of its
subsidiaries assumes no responsibility for any loss or damage resulting from the use of e-mails. The
recipient is aware of and accepts the inherent risks of using e-mails, in particular the risk that the
business relationship and confidential information relating thereto are disclosed to third parties. Kafou
Holding Co. or any of its subsidiaries reserves the right to retain and monitor all messages. Messages
are protected and accessed only in legally justified cases.
Need assistance or you didn't receive a reply? Kindly send your message to info@kafougroup.com . E-
mails can involve SUBSTANTIAL RISKS, e.g. lack of confidentiality, potential manipulation of contents
and/or sender's address, incorrect recipient (misdirection), viruses etc. Based on previous e-mail
correspondence with you and/or an agreement reached with you, Kafou Holding Co. or any of its
subsidiaries considers itself authorized to contact you via e-mail. Kafou Holding Co. or any of its
subsidiaries assumes no responsibility for any loss or damage resulting from the use of e-mails. The
recipient is aware of and accepts the inherent risks of using e-mails, in particular the risk that the
business relationship and confidential information relating thereto are disclosed to third parties. Kafou
Holding Co. or any of its subsidiaries reserves the right to retain and monitor all messages. Messages
are protected and accessed only in legally justified cases.
https://outlook.office.com/owa/projection.aspx 4/4