You are on page 1of 12

CONTRACTOR:   SUB COMPANY:  

CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 1 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

 
 
 
 
 
 
 
 
 
 
 

TATAOUINE GAS PROJECT  


TATAOUINE BRANCH LINE  
 
MANUAL HANDLING PROCEDURE 
 
 
 
 
 
 

 
 
 

             

18/12/2018   B01   Issued for approval   A.S SOUISSI   N.SOUISSI   A.CHABCHOUB    

Company
Date   Rev.   Description of Revision   Prepared by   Checked by   Approved by  
Approval  
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.  
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 2 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

TABLE OF CONTENT
 
ABBREVIATIONS ............................................................................................................................................................................ 3 

DEFINITIONS.................................................................................................................................................................................. 4 

TABLE OF HOLDS ........................................................................................................................................................................... 5 

1.  INTRODUCTION .................................................................................................................................................................. 6 

2.  OBJECTIVE .......................................................................................................................................................................... 7 

3.  SCOPE OF APPLICATION ..................................................................................................................................................... 7 

3.1  Scope .................................................................................................................................................................................. 7 

3.2  Responsibilities ................................................................................................................................................................... 7 

4.  PROCEDURE ....................................................................................................................................................................... 7 

4.1  Lifting Techniques .............................................................................................................................................................. 7 

4.1.1.  Bend at the knees .......................................................................................................................................................... 7 

4.1.2.  Grasp the load ............................................................................................................................................................... 7 

4.1.3.  Lift, using the legs ......................................................................................................................................................... 8 

4.1.4.  Carrying the load ........................................................................................................................................................... 8 

4.1.5.  Changing grip ................................................................................................................................................................ 8 

4.1.6.  Stacking ......................................................................................................................................................................... 8  

4.1.7.  Use of a lifting platform ................................................................................................................................................ 8 

4.2  Making an Assessment ....................................................................................................................................................... 3 

4.3  Safety Control Measures .................................................................................................................................................... 3 

4.3.1.  Task ............................................................................................................................................................................... 3  

4.3.2.  Load .............................................................................................................................................................................. 3 

4.3.3.  Working Environment ................................................................................................................................................... 3 

4.3.4.  Individual capability ...................................................................................................................................................... 4 

4.4  Common Injuries ................................................................................................................................................................ 4 

4.5  Training .............................................................................................................................................................................. 5 

 
 
 
 
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 3 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

ABBREVIATIONS
 
ETAP   :  Entreprise Tunisienne d'Activités Pétrolières 
HSE   :  Health, Safety And Environments 
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 4 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

DEFINITIONS
 

COMPANY (ETAP)   Is  the  party  which  carries  out  the  detailed  engineering,  Site 
management,  supplies  materials,  equipment  and  services  to 
perform the duties as specified by the CONTRACTOR / OWNER;  

COMPANY Representative  means the member and/or members appointed or designated by 
COMPANY in charge for the Double joint supervision on site as its 
duly  authorized  representative  to  deal  with  CONTRACTOR  with 
respect to the CONTRACT  

CONTRACTOR (RETEL)   Entity (and its legal successors in title) named as CONTRACTOR in 
the CONTRACTOR  
purchase order and/or the Contract awarded to the CONTRACTOR 
to perform specific services and/or works  

means the member and/or members appointed or designated by 
Work Method Statement   COMPANY in charge for the Double joint supervision on site as its 
(WMS)    duly  authorized  representative  to  deal  with  CONTRACTOR  with 
   respect to the CONTRACT  

Manual Handling  The  transporting  or  supporting  of  a  load  and  includes,  lifting, 
putting down, pushing, pulling, carrying, moving a load either by 
hand or by bodily force. 
 

 
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 5 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

TABLE OF HOLDS
 
 
Hold   Section   Comment
   
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 6 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

1. INTRODUCTION

The Tataouine Gas Project (TGP) is developed by ETAP. The project is intended to recover 
associated  and  non‐associated  gas  reserves  from  existing  concessions/permits  in 
Southern Tunisia. The TGP is composed of:  
- Dry and partially dew pointed gas from concessions being taken  from main 24” 
Nawara Pipeline at the Deviation Point.  
- A spur line which will deliver gas from Deviation Point to a Gas Treatment Plant 
(GTP‐T) located at Tataouine  
- The  GTP‐T  will  produce  Sales  Gas,  commercial  LPG  products  and  stabilized 
Condensate  
- Sales Gas will be delivered to customers at STEG reception point through dedicated 
product line  
- Separate  export  facility  by  road  tanker  will  be  provided  for  produced  LPG  and 
Condensate at the GTP‐T  
- Bottling Unit next to the GTP‐T LPG recovery plant.  

 
  
Figure 1 Project Location Map  

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 7 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

 
2. OBJECTIVE

To define the minimum requirements for manual handling during site activities 

3. SCOPE OF APPLICATION

3.1 Scope

CONTRACTOR Construction Sites. 

3.2 Responsibilities

CONTRACTOR Site Manager is responsible to implement the procedure. 

CONTRACTOR Site HSE Manager is responsible to make the site personnel aware of the 
contents of this procedure. 

4. PROCEDURE

4.1 Lifting Techniques

4.1.1. Bend at the knees

The weight to be lifted must be within the lifting capacity of the individual worker and the 
load should be approached squarely, facing the intended direction of travel. The feet are 
positioned about a hip’s width apart, one foot slightly in front of the body. The knees are 
bent and the body lowered as close to the load as possible while remaining relaxed and 
balanced. The back should be straight from hips to shoulders, but not necessarily vertical.                      

4.1.2. Grasp the load

The load is lifted with one hand (if necessary) so that the other hand can obtain a secure 
grip at the corner nearest the body. The free hand is  

Then  transferred  to  the  furthest  corner  of  the  load  and  drawn  as  close  to  the  trunk  as 
possible. Arms should be well tucked in to provide maximum support to the load.  

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 8 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

4.1.3. Lift, using the legs

The  load  can  be  lifted  by  straightening  the  legs  so  that  the  body  and  the  load  move 
upwards  in  unison.  All  movements  should  be  smooth  and  natural.  Jerking,  twisting,  or 
straining should be avoided. 

Lifting  should  feel  comfortable.  Lifting  movements  will  remain  smooth  and  natural 
providing the back and head are kept naturally erect. This is achieved by looking straight 
ahead when straightening the legs, instead of looking down at the load. 

4.1.4. Carrying the load

The load should be held firmly into the body and carried to where it is to be deposited. The 
closer the centre of gravity of the load can be kept to the body, the easier and more natural 
the lift. It is important to be able to see over or around the load so as to avoid tripping 
hazards. 

When the weight is approaching the maximum lifting capacity of the individual, it will be 
necessary to lean back on the hips with the load to bring the trunk to the erect position 
before straightening the legs to lift the load. In this instance the body is being used simply 
as a counterbalance to keep muscular effort to a minimum. 

4.1.5. Changing grip

Grips should not be changed while carrying the load. First rest the load on a ledge or other firm 
support, then change the grip if necessary. 

4.1.6. Stacking

Loads should not be lifted above shoulder height.  When it is impossible to lift and stack with the 
elbows tucked into the sides of the body, a platform should be used to stand on. An intermediate 
platform should also be used when lifting loads down from a higher level. 

4.1.7. Use of a lifting platform

The squad position is adopted as near to the load as possible. Keeping a straight back, and using 
the leg muscles, the load should be lifted onto a platform. The person lifting the load then stands 
as near to the platform as possible and, bending at the knees and hips (NOT at the back), eases 
the load onto his shoulder, adjusts for balance and straightens at the knees and hips.  

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
CONFINED SPACE
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 2 of 12  
TBL‐RETEL‐AA‐SF‐PR‐007  VENDER DOC. N°:     0004 

For lowering the load, the procedure is reversed. 

Carrying a load under one arm, supported on the hip, causes strain and should be avoided.

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
MANUAL HAANDLING
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 3 of 12  
TBL‐RETEL‐AA‐SF‐PR‐009  VENDER DOC. N°:     0006 

4.2 Making an Assessment

Any  work  that  requires  unusual  or  significant  manual  handling  shall  be  identified  and 
assessed to evaluate the risks associated to such task.  
 The assessment shall take into account: 
 The task to be done 
 The characteristics of the load (weight, ergonomics, etc.) 
 The  working  environment  (immediate  physical  surroundings  within  which  the 
handling operation takes place)  
The individual capability (physical characteristics of the people who are doing the handling 
operation and their ability in terms of knowledge, skills, health and strength) 
Tasks including significant or unusual manual handling shall be listed and updated. 

4.3 Safety Control Measures


4.3.1. Task

- Use mechanical aids to avoid as much as possible manual handling. 
- Redefine work sequences to remove unnecessary tasks, to prevent double handling, to 
prevent heavy carrying, to provide shelf storage for heavier objects at waist level, smaller objects on 
high or low shelves, etc. 
- Review work routine to reduce repetitive operations to allow more variation in movement 
and posture to provide rest breaks during heavy or repetitive work. 
- Identify resource needs (Manual handling by using work team). 

4.3.2. Load
- Modify / Break up loads so that individual items are lighter and/or smaller 
- If not possible to make the load smaller, hand grips or handles shall be provided 
- Redesign the load to be more stable and rigid 
- Make the load less damaging to hold 
- Mark loads to identify approximate weight and centre of gravity 

4.3.3. Working Environment


- Ensure appropriate housekeeping 
- Review ergonomic design of the work area 
- Reduce as much as possible changes of level 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.  
 
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
MANUAL HAANDLING
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 4 of 12  
TBL‐RETEL‐AA‐SF‐PR‐009  VENDER DOC. N°:     0006 

 
- Identify the most appropriate atmospheric conditions to facilitate handling activity 
- Identify approximate Personal Protective Equipment 

4.3.4. Individual capability

Allowance should be made for workers with temporary or permanent health problems, and pregnant 
women or new mothers, which may make them more liable to injury or less capable of undertaking 
the tasks without risk to others and to the load itself. 

4.4 Common Injuries

 Strains and sprains to muscles and joints, torn ligaments and tendons, disc trouble and 
hernias. These are often caused by sudden and awkward movements, e.g. twisting or jerking while 
lifting, or handling heavy loads. They are also caused by persons attempting to lift loads beyond 
their physical capabilities. The muscles of the abdominal wall are particularly vulnerable, and 
excessive strain may lead to ruptures. 

 Cuts and abrasions from rough surfaces, sharp or jagged edges, splinters, projections 
etc. personal protective equipment and clothing should be worn as necessary, such as leather 
gloves to protect the hands. 

 Back injuries are most frequently sustained while lifting and handling manually. They 
may be the cumulative effect of repeated minor injuries, or the result of an abrupt strain. Stoop 
lifting should be avoided. It greatly increases the chances of sustaining back injuries. The risk of 
injury is reduced by a knowledge of correct lifting techniques and by not attempting to lift 
excessively heavy loads without assistance 

 Crushing of limbs etc. by falling loads, fingers, hands or feet becoming trapped by loads. 
Correct positioning of hands and feet in relation to the movement of the load is essential. 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.  
 
CONTRACTOR:   SUB COMPANY:  
CONTRACTOR/VENDOR:
 

TATAOUINE GAS PROJECT


TATAOUINE BRANCH LINE  
   
MANUAL HAANDLING
  PROCEDURE    
Rev .   COMPANY DOC. N°:
CONTRACTOR DOC. N°:   SUB-CONTRACTOR / B01   TGP-RETEL-TBL-000-HS-PRO-
Sheet 5 of 12  
TBL‐RETEL‐AA‐SF‐PR‐009  VENDER DOC. N°:     0006 

 
4.5 Training

 Any person who is required to perform manual handling shall receive a general training 
which include as minimum: 
- Planning of manual handling sequences 
- Presentation of potential hazards related to manual handling 
- Recognised techniques for manual handling (see Attachment 1) 
- Use of suitable protective clothing  
- Probability of injury if the correct kinetic techniques are not used 
- Methods for self‐assessment of lifting activities for everyday manual handling activities 
 

 Manual handling shall be included in Toolbox talks and pre‐task briefings. 

 Training records shall be retained 

 
 

 
This document is the property of RETEL. Do not duplicate or circulate without the Authorization of RETEL.  
 

You might also like