Professional Documents
Culture Documents
Página 1 de 2
Shutdown SIS
Previous Screen
Specifications
3176B DIESEL TRUCK ENGINE
Media Number -SENR5560-01 Publication Date -01/03/1993 Date Updated -12/10/2001
Turbocharger (SB3)
(1) End play for shaft (new) ... 0.102 ± 0.025 mm (.004 ± .001 in)
(2) Thickness of thrust bearing (where thrust rings contact bearing) ... 5.36 ± 0.03 mm (.211
± .001 in)
(3) Diameter of shaft (new) ... 12.697 to 12.705 mm (.4999 to .5002 in)
Bore in the bearing (new) ... 12.741 to 12.748 mm (.5016 to .5019 in)
Maximum permissible clearance between bearing and shaft (worn) ... 0.05 mm (.002 in)
(4) Maximum permissible gap of oil seal ring, measured in bore of housing ... 0.25 mm (.010 in)
NOTICE
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/s... 09/12/2011
3176B Truck Engine CARB-Certified - ATAAC 9CK00001-UP(SEBP2047 - 23) - ... Página 2 de 2
d. Loosen the nut and tighten again to 9 N·m (80 lb in) plus an additional 60 degrees (1/6 turn).
NOTICE
Do not bend or add stress to the shaft when the nut is loosened or
tightened.
(6) Thickness of each thrust ring ... 2.553 ± 0.013 mm (.1005 ± .0005 in)
(7) Bore in housing (new) ... 20.744 to 20.757 mm (.8167 to .8172 in)
Outside diameter of the bearing (new) ... 20.630 to 20.643 mm (.8122 to .8127 in)
Maximum permissible clearance between bearing and bore in housing (worn) ... 0.15 mm (.006 in)
Torque for four nuts (put 5P3931 Anti-Seize Compound on threads) and bolts that hold
turbocharger to exhaust manifold ... 55 ± 5 N·m (40 ± 4 lb ft)
Install the band clamps to hold the cartridge to the compressor housing as follows:
NOTE: Put clean engine oil in the oil inlet of the turbocharger after assembly or before
installation to provide start up lubrication and/or storage protection.
Copyright 1993 - 2011 Caterpillar Inc. Fri Dec 9 09:32:57 EST 2011
All Rights Reserved.
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/s... 09/12/2011