The monthly integrity report from the UGDC Chemical Laboratory Department summarizes gas and liquid sample analysis from July 2008. Gas samples taken from the El Gamil feed, Ha'py feed, and feed mix lines contained average H2S and CO2 levels within the monthly maximum values. Liquid samples from drain drums and hot oil contained water levels, TDS, chlorides, and acidity within specification. Signatures from the lab team leader verified the report.
The monthly integrity report from the UGDC Chemical Laboratory Department summarizes gas and liquid sample analysis from July 2008. Gas samples taken from the El Gamil feed, Ha'py feed, and feed mix lines contained average H2S and CO2 levels within the monthly maximum values. Liquid samples from drain drums and hot oil contained water levels, TDS, chlorides, and acidity within specification. Signatures from the lab team leader verified the report.
The monthly integrity report from the UGDC Chemical Laboratory Department summarizes gas and liquid sample analysis from July 2008. Gas samples taken from the El Gamil feed, Ha'py feed, and feed mix lines contained average H2S and CO2 levels within the monthly maximum values. Liquid samples from drain drums and hot oil contained water levels, TDS, chlorides, and acidity within specification. Signatures from the lab team leader verified the report.
Sample Location CO2 Mol% WDP °C Max. value/ Max. value/ Frequency wt. as S Month Month Daily El Gamil Feed Gas (Averaged) 0.8067 <0.1 +4.24 0.8296 +5.00 Daily Ha’py Feed Gas (Averaged) 0.1607 <0.1 N/A 0.2065 N/A Daily Feed Mix (Averaged) 0.8002 <0.1 +3.85 0.8332 +5.00 D/S Dehydration Daily 03-R-01A/D (Averaged) 0.8027 <0.1 -77.30 0.8482 -76.10 H2O wt % pH TDS ppm Conductivity µs Liquid from Inlet Separator 02-V-01 Monthly No level in the inlet separator Liquid from Coalescer 03-F-04 Monthly N/A H2O ppm- TDS Chlorides Mercaptan ppm wt ppm ppm Cold Drain Drum Liquid 96-V-02 (1) Monthly 79.85 - - N/D Warm Drain Drum Liquid 96-V-01 (2) Monthly 81.73 634 289.6 N/D H2O ppm- Acid No. BS&W ml wt mg KOH/g
Hot Oil Quarter 237.3 0.195 0.05
H2O ppmv.
Absorber Bottoms Yearly -
TDS ppm pH Outlet Regen Gas KO Drum 03-V-03 Every 2 Months - - Remarks: (1) this sample was one phase and Relative Density @ 60/60 F was 0.7529 where by chromatographic analysis it was condensate (2) This sample was two phases where the results highlighted in the table performed on second phase. First phase: the Relative Density @ 60/60 F was 0.6825 also by chromatographic analysis it was condensate Second phase: the Density @15 °C was 1.1144 g/cm³ and conductivity was 1266 µs where from its analysis mention above it was Glycol and the results of TDS and Chloride for this phase only Signature: Hany El-Gamal Date: 7/8/2008 UGDC Chemical Laboratory Department