Professional Documents
Culture Documents
Experiment 3: Redox Titration
Experiment 3: Redox Titration
REPORT
EXPERIMENT 3: REDOX TITRATION
You have to submit both:
+ Electronic copy: Submitted through BlackBoard
Deadline: Please check on BlackBoard
+ Hard copy: Submitted to Instructor/TAs
Deadline: At lab entry of Experiment 4
Score: _________
Last updated: 07/05/2016 by Assoc. prof. Huynh Kim Lam & M.Sc. Le Nguyen Thien Phuc
*
This report MUST BE TYPED and handed in together with the signed data sheet
International University, Vietnam National University - HCMC 2
GENERAL CHEMISTRY LABORATORY
Trial
Burette reading (mL) Volume of KMnO4 (mL) Normality of KMnO4 (N)
#
1 16mL - 27.2mL 11.2 mL 0.044 N
Comment:
In this experiment, First we pipeted 10mL of standard oxalic acid solution into two
250mL Erlenmeyer flasks. Then , approximately 40mL of distilled water was added
to each flask. After that ,we cautiously added 20mL of o 6N H2C2O4 solution to each
flask. Warming the flasks in the water bath to 85–90 C and titrating the hot
solutions against the KMnO4 solution were done at the end. We are required to add
the KMnO4 solution very slowly initially . We had better know End point for this
experiment refers to the titrant volume needed to keep the faint pink color
throughout the stirred solution for at least twenty seconds.At the end of this step we
recorded the buret reading and calculated the normality of the KMnO4 solution.the
results are shown in the table above.
We apply the formula to calculate normality:
Flask 2
2. TITRATION OF UNKNOWN CONCENTRATION H2C2O4 SOLUTION WITH
STANDARD KMnO4 SOLUTION
Last updated: 07/05/2016 by Assoc. prof. Huynh Kim Lam & M.Sc. Le Nguyen Thien Phuc
*
This report MUST BE TYPED and handed in together with the signed data sheet
International University, Vietnam National University - HCMC 3
GENERAL CHEMISTRY LABORATORY
Trial # Burette reading (mL) Volume of KMnO4 (mL) Normality of H2C2O4 (N)
Comment:
Last updated: 07/05/2016 by Assoc. prof. Huynh Kim Lam & M.Sc. Le Nguyen Thien Phuc
*
This report MUST BE TYPED and handed in together with the signed data sheet
International University, Vietnam National University - HCMC 4
GENERAL CHEMISTRY LABORATORY
Comment:
Last updated: 07/05/2016 by Assoc. prof. Huynh Kim Lam & M.Sc. Le Nguyen Thien Phuc
*
This report MUST BE TYPED and handed in together with the signed data sheet