Professional Documents
Culture Documents
DS 0.08 MECHANIC
REFERENCE DESIGNATION
None specified Container, one quart (1L) capacity
B. Parts
REFERENCE DESIGNATION
TASK 49−30−00−790−801 APU Fuel and Oil Leak Check
3. Removal Job Set−Up
A. Open and remove the access doors as follows:
ACCESS DESIGNATION
311BB Aft equipment−compartment door
311BZ APU enclosure door
B. Open, safety, and tag the circuit breakers that follow:
DS 0.08 MECHANIC
4. Removal Procedure
Refer to Figure 1.
WARNING: OBEY ALL THE FUEL SAFETY PRECAUTIONS WHEN
YOU DO WORK ON THE FUEL SYSTEM AND/OR A
FUEL SYSTEM COMPONENT. IF YOU DO NOT DO
THIS, YOU CAN CAUSE INJURIES TO PERSONS
AND/OR DAMAGE TO EQUIPMENT.
A. Remove the APU fuel−filter element as follows:
(1) Put the container below the APU fuel−filter element to
collect fuel leakage.
(2) Loosen, but do not remove, the bolts that hold the cover
(1).
(3) Turn the cover (1) a small distance to disengage it from
the bolts.
(4) Remove the cover (1) and the fuel filter element (3), then
drain the unwanted fuel into the container. Discard the
preformed packing (2) from the cover (1).
(5) Remove and discard the fuel filter element (3) and the
preformed packing (4).
5. Installation Job Set−Up
A. Make sure that the aircraft is in the same configuration as in
the removal task.
6. Installation Procedure
Refer to Figure 1.
WARNING: OBEY ALL THE FUEL SAFETY PRECAUTIONS WHEN
YOU DO WORK ON THE FUEL SYSTEM AND/OR A
FUEL SYSTEM COMPONENT. IF YOU DO NOT DO
THIS, YOU CAN CAUSE INJURIES TO PERSONS
AND/OR DAMAGE TO EQUIPMENT.
A. Install the APU fuel−filter element as follows:
(1) Make sure that there is no contamination in the cover (1).
(2) Lubricate the preformed packing (4) with fuel used in the
system. Install the packing (4) in the groove in the fuel
filter element (3).
DS 0.08 MECHANIC
(3) Lubricate the preformed packing (2) with fuel used in the
system. Install the packing (2) on the cover (1).
(4) Put the fuel−filter element assemblies (3) and (4) in the
cover (1).
(5) Install the cover (1) on the fuel control unit. Turn the cover
(1) a small distance to engage the bolts, then tighten the
bolts.
(6) Remove the container and clean all fuel leakage.
7. Close Out
A. Remove the tags and close the circuit breakers that follow:
ACCESS DESIGNATION
311BB Aft equipment−compartment door
311BZ APU enclosure door
DS 0.08 MECHANIC
AIRCRAFT EFFECTIVITY:
2
LEGEND.
1. Cover.
2. Preformed packing.
1 3. Fuel filter element.
4. Preformed packing.