Professional Documents
Culture Documents
Sir Minilink Comcel 16-06-2011 Documento Base
Sir Minilink Comcel 16-06-2011 Documento Base
GENERAL INFORMATION
1 Site Information
1.1 Address:*)
2 Customer References
4.2 Address:
5 Local regulations
5.1 Are there any special health and safety regulations that need to be
considered? Yes Casilla
No de verificación
Casilla
N/Ade verificación
664
Casilla de 664
verificación
If yes, note which ones:
5.3 Are there any other local regulations, which will effect the installation
on this site? Yes Casilla
No de verificación
Casilla
N/Ade verificación
664
Casilla de 664
verificación
If yes, note which ones:
5.4 Other:
6 Site Access
6.1 Are there any special site accessibility requirements that need
to be considered? Yes No de verificación
Casilla N/Ade verificación
Casilla 664
Casilla de 664
verificación
If yes, note which ones:
6.4 Do the visitors need to register and/or obtain working pass? Yes No de verificación
Casilla N/Ade verificación
Casilla Casilla de664
664 verificación
If yes, note location of security office / Fire Command Center:
6.6 Are there any other site access restrictions? *) Yes No de verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note what:
6.7 Is use of GPS receiver instrument allowed at the site? Yes No de verificación
Casilla N/Ade verificación
Casilla Casilla de664
664 verificación
Which are the geographical coordinates for the site?
6.8 Other:
4 (39)
7.1 Are the roads to the site suitable for material transportation and
working vehicles? *) Yes No de verificación
Casilla Casilla de664
N/Ade verificación
Casilla 664 verificación
Is there any risk for leakage or flooding in the room? Yes No de verificación
Casilla N/Ade verificación
Casilla 664
Casilla de 664
verificación
Is the room fire protected? Yes No de verificación
Casilla N/Ade verificación
Casilla 664
Casilla de 664
verificación
Can the room be locked? Yes No de verificación
Casilla N/Ade verificación
Casilla 664
Casilla de 664
verificación
1 Equipment Information
Fill in the type of equipment to be installed and data for the equipment in the table below:
2 Site Requirements
Are there any existing external alarms installed? Yes Node verificación
Casilla N/A
Casilla de verificación
664Casilla de
664
verific
If yes, which type of alarms?
3.4 Make a sketch of the equipment location area incl. any existing equipment on the Aerial Placing
Sketch.
Take all necessary measurements and note them on the Aerial Placing Sketch.
At extension and if existing Aerial Placing Information is used as basis, check and verify the
information on the drawing.
Select a location for the equipment to be installed and draw it on the Aerial Placing Sketch/Aerial
Placing Information.
Note all necessary installation measurements.
3.5 Other:
Casilla de verificación
Casilla de verificación
664Casilla de
664
verific
8 (39)
4.6 Other:
5.1 Will an optical interface link be connected to the equipment? Yes Node verificación
Casilla N/A
Casilla de verificación
664Casilla de
664
verific
5.2 Other:
6 Grounding
6.2 Mark the existing ground electrode on the Aerial Placing Sketch. At extension and if existing
Aerial Placing Information is used as basis, check and verify the information on the drawing.
Note all necessary installation measurements.
6.3 Other:
9 (39)
7 Transmission
7.1 Is there an existing outdoor cabinet for the transmission equipment? Yes Node verificación
Casilla N/A
Casilla de verificación
664Casilla de
664
verific
If yes, note following:
Outdoor cabinet type including standard for mounting brackets:
Available depth for the equipment in the cabinet:
Available height for the equipment in the cabinet:
Make a sketch of the space assigned in the outdoor cabinet for the transmission equipment in
the Equipment Allocation Sketch.
8.2 Make a DF allocation sketch in the Equipment Allocation Sketch for each concerned DF type,
if this shall be documented.
8.3 Other:
10 (39)
9 Cable Routes
9.1 Are there any existing cable routes, which can be used? Yes Node verificación
Casilla N/A
Casilla de verificación
664Casilla de
664
verific
If yes, note following:
Type: Dimensions:
Available space:
9.3 Draw the cable routes on the Aerial Placing Sketch. At extension and if existing Aerial Placing
Information is used as basis, check and verify the information on the drawing.
Note all necessary installation measurements.
9.4 Other:
Type of site cables (power, traffic, external alarms, grounding, etc.) Required length (m)
Radio Cable
Grounding Cable
Power supply DC
Cable UTP
10.3 Other:
### Other
Take pictures to back up the notes, if allowed.
Fill in information about the pictures in the Picture Overview List
11 (39)
EXISTING MW NEW MW
Antenna
Number of antennas
Antenna Azimuth (Deg)
Antenna Elevation (Deg)
Antenna module type (GHz)
Antenna diameter (m)
Antenna height (m a g l)
Antenna Polarization
Antenna Mounting
Waveguide length (m)
Antenna support type (mast)
Radio
Radio unit type RAU ERICSSON
Radio unit sub-band
Number of radio units
Power Splitter
Type Asymmetric
Mounting type
Waveguide length (m)
Radio cable
Radio cable length (m)
20 (39)
1 Antenna Information
Fill in the type of antenna products to be installed and data for the antenna products
in table below:
2 Site Requirements
2.5 Other:
21 (39)
Does a new antenna support structure need to be supplied? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificació
Qty Dimensions
Guyed mast on ground
Self-supported tower on ground
Other structure on ground:
Qty Dimensions
Other:
3.4 Make a sketch of the antenna placement area including any existing equipment and existing or
new antenna support structure on the Aerial Placing Sketch.
Take all necessary measurements and note them on the Aerial Placing Sketch. At extension
and if existing Aerial Placing Information is used as basis, check and verify the information on
the drawing.
3.6 Is use of GPS receiver instrument allowed at the site? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificació
3.7 Which are the geographical coordinates for the antenna system?
Or if applicable, specify geographical coordinates for each antenna in the table below:
3.9 Check the compass direction towards a fixed construction e.g. the building and note it on
the Aerial Placing Sketch/Aerial Placing Information.
3.10 Establish suitable antenna locations and mark them on the Aerial Placing Sketch/Aerial Placing
Information.
Note all necessary installation measurements.
3.11 Are there any possible obstacles in the antenna directions? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificació
If yes, make a note in the Protractor Sketch.
3.12 Other:
24 (39)
4.1 Are there any existing feeder cable routes, which can be used? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificació
If yes, note following:
Type: Dimensions:
Available space:
4.2 Do new feeder cable routes need to be installed? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificació
If yes, note following:
Type: Dimensions:
4.3 Draw the feeder cable routes on the Aerial Placing Sketch. At extension and if existing Aerial
Placing Information is used as basis, check and verify the information on the drawing.
Note all necessary installation measurements.
4.4 NOTE! Calculate required feeder lengths and fill in site dependent feeder cables data
4.5 Indicate the location of the equipment room/outdoor cabinet on the Aerial Placing Sketch.
At extension and if existing Aerial Placing Information is used as basis, check and verify the
information on the drawing.
4.6 Other:
5 Grounding
5.3 Mark the existing ground electrode, bonding bar and lightning conductor on the Aerial Placing Sketch.
At extension and if existing Aerial Placing Information is used as basis, check and verify
the information on the drawing
Note all necessary installation measurements.
5.4 Other:
25 (39)
6.3 Other:
27 (39)
7 Other
Sketch (Protractor)
Comments: (e.g. obstacles seen from site within a radius of Casilla de100-500m
verificaciónor
664 1-5
Casilla dekm)
verificación 664
29 (39)
1 Equipment Information
Fill in the type of equipment to be installed and data for the equipment in the table below:
2 Site Requirements
2.6 Environment requirements: Operational temperature -50°C to+60°C (Outdoor full functionality)
Operational temperature -25°C to+55°C (Indoor full functionality)
2.8 Other:
31 (39)
Will painting of walls, floor and/or ceiling be necessary? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note where:
Are there any windows that might have to be covered? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
Are there power outlets for tools? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
Is there sufficient lighting? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
Is the room tidy and clean? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If no, what needs to be taken care of?
Are there any existing external alarms installed? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, which type of alarms?
3.4 Make a sketch of the equipment room including any existing equipment on the Floor Plan Sketch.
Take all necessary measurements including ceiling height and note them on the Floor Plan Sketch.
At extension and if existing Floor Plan Drawing is used as basis, check and verify the information
on the drawing.
Select a location for the equipment to be installed and draw it on the Floor Plan Sketch/Floor
Plan Drawing.
Note all necessary installation measurements including installation height above floor level
if applicable.
3.5 Other:
32 (39)
4.2 Are the AC-mains provided with Over Voltage Protection (OVP)? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes indicate type of OVP:
4.7 Other:
33 (39)
5.1 Will an optical interface link be connected to the equipment? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
5.2 Other:
6 Grounding
6.2 Is there an existing Main Earth Terminal (MET) in the equipment room,
which can be used? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note following:
Free positions:
Terminal screw dimensions:
6.3 Mark the MET on the Floor Plan Sketch. At extension and if existing Floor Plan Drawing
is used as a basis, check and verify the information on the drawing.
Note all necessary installation measurements including installation height above floor level.
6.4 Other:
7 Transmission
7.1 Is there an existing rack/cabinet for the transmission equipment? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note following:
Rack/cabinet type:
Rack/cabinet hole pattern:
Available depth for the equipment in the rack/cabinet:
Available height for the equipment in the rack/cabinet:
Make a sketch of the space assigned in the rack/cabinet for the transmission equipment in
the Equipment Allocation Sketch.
Make sure to include the transmission rack/cabinet on the Floor Plan Sketch.
7.2 Other:
34 (39)
8.2 Make a DF allocation sketch in the Equipment Allocation Sketch for each concerned DF type,
if this shall be documented.
8.3 Other:
Is there a priority diagram for the equipment at the site? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
9 Other:
35 (39)
10.1 Are there any existing cable inlets, which can be used? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note following:
Dimensions: Inlet height:
Available cable glands:
10.3 Draw the cable inlets on the Floor Plan Sketch. At extension and if existing Floor Plan
Drawing/Cable Way Drawing is used as basis, check and verify the information on the drawing.
Note all necessary installation measurements including installation height above floor level.
10.4 Are there any existing cable routes, which can be used? Yes Node verificación
Casilla N/Ade verificación
Casilla 664
Casilla de664
verificación
If yes, note following:
Type: Height:
Dimensions: Available space:
10.6 Draw the cable routes on the Floor Plan Sketch. At extension and if existing Floor Plan
Drawing/Cable Way Drawing is used as a basis, check and verify the information on the drawing.
Note all necessary installation measurements including installation height above floor level.
10.7 Other:
36 (39)
Type of site cables (power, traffic, external alarms, grounding, etc.) Required length (m)
Power DC
Coaxial Cable 75 Ohmios
UTP cable
Grounding Cable
And others you suggest
11.3 Other:
37 (39)