Professional Documents
Culture Documents
34. Install springs (16) (2 used) to center shafts (15) 41. Install right regulator (2) into pump casing (51),
(2 used). according to the following procedure.
• Adjust the sleeve position so that the grooves in
35. Insert center shafts (15) (2 used) and plungers both sleeves on the right regulator are in a line.
(17) (14 used) into rotors (18) (2 used). • Put the right regulator on the pump casing, install
pin (59) for link (79) into the both grooves in the
36. Insert a file’s shank etc. into the center hole of sleeve.
center shaft (15), rotate the center shaft to install • Move the right regulator, so that spring pin (54)
pin (14) into the groove of rotor (18). (Both right extended from the pump casing can enter into the
and left pump) right regulator.
• Install the right regulator into the pump casing
NOTE: If the pin does not enter into the groove of with socket bolts (1) (4 used).
the rotor, selector head (66) cannot be as- : 8 mm
sembled to pump casing (51). : 49 N⋅m (5 kgf⋅m, 36 Ibf⋅ft)
59
37. Apply a film of LOCTITE LI829 to the threads of 2 Sleeve
pins (61) (4 used), and then install the pins to
valve plates (62, right) and (77, left).
: 7 mm
: 9.8 N⋅m (1 kgf⋅m, 7.2 Ibf⋅ft)
W178-02-04-014
45. Install pin (74) into servo piston (73), fix the servo
piston with set screw (72). (Both right and left
IMPORTANT: Pay attention to the mounting direc- servo pistons)
tion of left regulator (77). Beforehand, apply a film of LOCTITE LI829 to the
threads of the set screw.
39. Insert pins (61) (2 used) for left valve plate (77) : 6 mm
into the hole of levers (60) (2 used) for left regu- : 34.3 N⋅m (3.5 kgf⋅m, 25 Ibf⋅ft)
lator (6), and install retaining rings (58) (2 used).
W2-4-19