Professional Documents
Culture Documents
Acceptance
Tools
criteria
Note the supplier's name and the cam batch number on the traceability
component record sheet C1000 in C 405 (see procedure MO 22)
a) Install the cam supports on the table (OP 011) with tools 1 to pre-position
them
Tool 1: 11258407
c) Tighten the attaching screws and then consecutively drill and ream the
supports with the transfer plate (OP 011)
10005365500201EN.xls
OP : A 405
DIVISION BLOWING & COATING Setup diagram Page : 2/4
Revision : B
MACHINES : SBO UNIVERSAL ET HIGH SPEED Date : 28/03/06
Stop
Tooling
11258407
Cam support
Tooling
11258407
Side connector
for SBO PM
A
10005365500301EN.slddrw
Assembly instruction procedure
BLOWING & COATING DIVISION
Acceptance
Tools
criteria
f) Adjust the level of the straight parts of the cam (infeed and outfeed) of the
mold base raising/lowering cam
Housing
10005365500201EN.xls
OP : A 405
DIVISION BLOWING & COATING Setup diagram Page : 4/4
Revision : B
MACHINES : SBO UNIVERSAL & HIGH SPEED Date : 28/03/06
Côte B
Rule
Rotating plate
for SBO PM
Côte B
Cote = 194 mm
Cam support
Dial gauge
10005365500401EN.slddrw
Fiche d'instruction de montage
DIVISION BLOWING & COATING
Critères
Outillages
d'acceptation
1) Put the tool in the axis of the rotating plate (position 1) and center on the cam
Tighten it with the screw (M16)
Tool : To number
10005365500201EN.xls
Fiche d'instruction de montage
DIVISION BLOWING & COATING
Critères
Outillages
d'acceptation
4) Turn the rotating plate to put the tool at the cam output
3) Adjust the gap at 5/100 between cam and feeler gauge to have the
dimension B
10005365500201EN.xls
Inspection record form
BLOWING & COATING DIVISION
Remarks:
10005365500501EN.xls