Professional Documents
Culture Documents
2021-2022
TANTA UNIVERSITY Section (3) FACULTY OF ENGINEERING
Soil Plasticity
Presented by
Eng. Alaaeldin Magdy
حد السيـولة )Liquid Limit (L.L
Soil Plasticity: لدونـة التربـة
It is the smallest water content at which the soil is liquid but still has a certain value
تصنيف التربة وفقـا لقوام التربــة Soil Classification according to soil consistency:
of shear strength. أقل محتوي ميـاه للتربة في الحالـة السائلة ولكن مازالت محتفظة بجزء صغير لمقاومة القص
حدود القوام بتكون للتربة الناعمة فقط (طين – طمي)
1- Liquid Limit Test: اختبـــار حد السيولـــة خطوات التجربة:
.1يتم احضار عينة التربة الجافة وخلطها بكمية
مناسبة من الماء بحيث تعطي قوام متماسك
لوتبقي علي وعاء التجميع ) (Panبتاع اختبـار لو عينة التربة اللي جاية من
.2توضع العينة في علبة مغلقة وتترك 24
المناخل أكبر من %50من وزن العينة الجسـة تربة ناعمة سـاعة لضمان انتشار الماء داخل العينة.
ده معناه ان المكون الرئيسي ليـها كان مواد ناعمة .3نأخذ جزء من العينة وتفرد داخل الطبق
المعدني لجهاز كاسجراند.
Slurry of soil Stress حاالت القـوام:
.4يتم عمل شق طولي في العينة باستخدام
روبة من التربـة يوجد 4حاالت للقوام يفصلهم 3حدود سكينة كاسجراند
تسمي بحدود أتربرخ:
4- Liquid State 𝐖𝐜 > L.L .5ندور يد الجهاز ليرتفع الطبق مسـافة 1سم
بجيب عينة التربة واحسبلها الـ W.C ويسقط تحت تأثير وزنه بمعدل خبطتين في
Very Soft to Soft strain الثانية.
لينة الي ضعيف التماسك
Stress .6نحسب عدد الضربات الالزمة الغالق جزء
زي قالب الزبدة )Liquid Limit (L.L
من الشق بطول نص بوصة حوالي 13مم.
3- Plastic State حد السيـولة
زيادة محتوي الميـــاه 𝐖𝐜 %
مالحظات
لو حبل التربة اتقطع قبل ما يصـل لقطر 3مم معناه ان العينة جـافة ومحتاج أزود ميـاه باستخدام بخـاخ
لو حبل التربة وصل لـ 3مم ولم يتقطع يبقي محتوي الميـاه اللي ضيفته للتربة كان كتير أكبر من حد اللدونة
Alaaeldin
Ex (1): During a laboratory test conducted on a Solution: 2- Plastic limit (L.L) حد اللدونة
sample of a cohesive soil, it was found that the 1- Liquid limit (L.L)
38.2 + 39.4 + 40.8
water content at which a groove of a length of P.L = = 39.4%
برسم عالقة مابين محتوي المياه وعدد الضربات علي-1 3
0.5 inch could be closed after 25 blows in 𝐖𝐜 %
.منحني نصف لوغاريتمـي 3- Plasticity Index (P.I) دليل اللدونة
Casagrande apparatus was 60.1%. If the plastic 86
limit on a sample of the same soil was 23.2%, سم8 مسافة اختيـارية ولتكن100 و10 أفرض المسـافة بين-2 P.I = L.L – P.L = 75 – 39.4 = 35.6%
84
Calculate the plasticity index.
82
مثال علي المحور األفقي15 لتوقيع عدد الضربـات-3 4- Void ratio (e)
Given: L.L = 60.1% P.L = 23.2%
• Void ratio at L.L L.L = 𝐖𝐜 = 75%
Solution: P.I = L.L – P.L = 60.1 – 23.2 = 36.9% 80 𝟏𝟓
𝐗 𝟏 = Log × 8 = 1.4 cm
𝟏𝟎 𝐒𝐫 . e 𝐒𝐫 = 100%
Ex (2):The following data were obtained on a liquid
78 𝐖𝐜 =
𝐆𝐬
limit test on a clay sample: 76
𝟏×e
Number of blows,
10 15 22 30
75
74
0.75 =
𝟐.𝟕𝟎
e = 2.025
N
Water Content, 72 • Void ratio at P.L P.L = 𝐖𝐜 = 39.4%
85.1 80.2 76.2 73.8
𝐖𝐜 (%)
𝐒𝐫 . e 𝐒𝐫 = 100%
In addition, three plastic limit tests conducted 10 15 22 25 30 100 Log N 𝐖𝐜 =
𝐆𝐬
on the same soil gave water contents of 38.2%, 3.18 Number of blows
39.4 and 40.8%. If the specific gravity of the 𝟏×e
soil is 2.70, Determine the liquid limit L.L.,
3.8 0.394 = e = 1.064
2.74 𝟐.𝟕𝟎
plastic limit P.L., plasticity index P.I. and the 1.4
void ratio "e" corresponding to these limits. 8 cm
{Hint: 𝐖𝐜 % = (S% * e) /Gs}
Given: Required: 𝟐𝟐
𝐗 𝟐 = Log × 8 = 2.74 cm
𝟏𝟎
P.L𝟏 = 38.2% 1- L.L 2- P.L
𝟑𝟎
P.L𝟐 = 39.4% 3- P.I 4- e
𝐗 𝟑 = Log
𝟏𝟎
× 8 = 3.8 cm L.L= 75 %
P.L𝟑 = 40.8% 𝟐𝟓
𝐗 𝟒 = Log × 8 = 3.18 cm
𝟏𝟎
𝐆𝐬 = 2.70 L.L P.L Alaaeldin
Prop. Of soil Acc. To Atterberg limits Ex (3): The following data was given for two soils:
a) Which of these soils contains more clay particles, and why?
1- Plasticity Index (P.I) دليل اللدونة
Soil L.L (%) P.L (%) 𝐖𝐜 (%) b) Classify these soils using the Casagrande plasticity (A-Line) chart.
P.I = L.L – P.L 𝐏. 𝐈𝐂𝐥𝐚𝐲 > 𝐏. 𝐈 𝐬𝐢𝐥𝐭
A 36 25 30 c) Determine the consistency index and liquidity index of each soil.
2- Relative Consistency (𝐂𝐫 ) القوام النسبي
B 74 31 45 (A-Line) chart. وتستخدم لتصنيف التربةL.L & P.I هو عالقة مابين
Or Stiffens of soil 𝐋.𝐋 −𝐖𝐜 P.I
𝐂𝐫 = P.I (Line) = 0.73 (L.L -20) :معادلة الخط المستقيم
𝐋.𝐋 −𝐏.𝐋
Solution:
Soil A Soil B
𝐂𝐫 < 0 (-ve) 𝐂𝐫 = 0 - 1 𝐂𝐫 > 1 P.I = L.L – P.L P.I = L.L – P.L
Very soft to soft Med. Stiff to stiff Very stiff to hard Clay with
P.I = 36 – 25 = 11% P.I = 74 – 31 = 43% 43 high
3- Liquidity Index (L.I) دليـل السيولة plasticity
𝐖𝐜 −𝑷.𝑳 Clay with
L.I = P.I Soil B contains more clay
𝑳.𝑳 −𝑷.𝑳 Clay with low Med
plasticity plasticity
Consistency index 𝑳 = 𝑪 القوام النسبي.𝑳 −𝐖𝐜
𝒓
L.I = 0 - 1 𝑳.𝑳 −𝑷.𝑳 Silt with high
L.I < 0 (-ve) L.I > 1 11 Compressibility
Very stiff to hard Med. Stiff to stiff Very soft to soft Soil A Soil B
4- Volumetric Change التغيـر الحجمي 𝟑𝟔 − 𝟑𝟎 𝟕𝟒 −𝟒𝟓
Shrinkage limit حد االنكماش 𝑪𝒓 = = 0.545 𝑪𝒓 = = 0.674 36 74
𝟑𝟔 −𝟐𝟓 𝟕𝟒 −𝟑𝟏
𝐖𝐰
𝐖𝐜 % = × 100%
A < 0.75 A = 0.75 – 1.25 A > 1.25 𝐖𝐝
Inactive Clay Normal Clay Active Clay Alaaeldin