Professional Documents
Culture Documents
injection degree?
on board LO test
what is HSS?
Cat fine?
purifier maitanence?
solas certificate?
what is PCB?
what are the checks to be done after overhauling of axillary engine piston?
boiler tube leaking indication?
4E duty
After 6-7 days of changeover from HFSO to LFSO all unit blast why?
Bunker procedure.
FO onboard testing procedure water test, compatibility test, viscosity test & more 3 test.
ISM,SMC,DOC,IOPP
Incinerator safety, trip, regulation, temp setting procedure, alarm testing procedure.
Bearing clearance how much, Piston liner wear rate & how much?
Survey procedure
What is the energy requirement for navigation battery & how much time?
Operating procedure.
Safety device.
Uptake fire
Batch purification.
Bunker documentation.
Faraday's law.
Sensing probe principle and how it is work ,material of probe.
SOLAS area
Incinerator regulation.
Bunker checklist
IOPP,IAPP,SMC,PMS,COC
Synchroscope?
Piston clearance
Drawing
Oil cooled piston
Co2 flooding for hold
Liner
Power distribution
Fuel oil line
Incinerator line diagram
Boiler water level controller
Earth fault
After taking over watch what should you wirte in the log book
Co2 flooding in E/R procedure, function of pilot v/v, during floodin why ventilation fan &
blower trip?
Scavenge fire alarm how you will understand that alarm is correct.
A/E L.O temp how much & L.O press drop a little what you check.
Function of purifier
shifting of interface
bad fuel and big dia of gravity disc what is the solution
change to clarifier
bottom end bolt tension importance, tension is not accurate ,what will be problem?
(OWS regulation for in special and outside special area ,machinery space bilge, slop tank
Regulation ,operation, alarm and alarm test)
boiler low low water level how to sure ,what are the cause what is your action at sea
if water is not come out in water cock why not put feed water
boiler alarms, two safety valve in same chest why ,how to test safety valve when in operation,
not in operation
feature of cascade tank oil how to find out from which tank?
How understand pump suction line is air present ,find out, action
what is problem if discharge press low but pump running, how air can ingress through pump
Documents, Boiler Soot blow, procedure, action. Economizer washing, Wash water
management
Details (scavenge fire, Starting line explosion, Crankcase Explosion), action in case of O.M.D.
Alarm
Scavenge limiter
auxiliary engine major overhauling risk assessment (special concern to given about the risk
factor i,e. how the multiplication done, write down the risk assessment )
Crankcase explosion(details), oil mist detector alarm(as a third engr what to do),if bridge
doesn’t allow to stop the engine what will be my action
OWS starting procedure ( including what needs to be written in ORB, after bunker what is
written in orb-logbook)
After taking over watch what papers needs to be maintain -its related to the log book ,weekly
what is written in the ORB,OWS regulation
Safety check list(details i,e. Specially during bunker what needs to be maintain according to
safety checklist)
Regarding manometer-if there is no liquid inside the manometer what to do as a duty engineer.
Draw
Sewage treatment plant
Bulkhead Cross-section
Star Delta connection.
Boiler Gauge glass
Star Delta Connection
Emergency Switchboard
Arafat sir :-
Drawing:
CO2 flooding
fresh water generator
fuel oil analysis test contents
Incinerator line diagram
written:
- Economizer water washing procedure
FWG
Explain drawing
How vacuum is created. Vacuum pressure
What is demister. What does it do.
Why vacuum is not raising in FWG
Then vacuum breaker
Salinometer purpose
Action due to less efficiency
Drinking treatment Safety
Sterilizing chlorine content how much , FWG regulation
Co2:
Explain the drawing
Line test and why
Bottle pressure safety vv blow pressure , line pressure
Regulation
Pressure switch function
Time delay why?
Bottle number.
* f.w.g why vacuum not build up? How to check the brine level?
* solas certificate.
* sopep item.
* sampling methods.
Burner maintenance
Difference btwn safety v/v and releave v/v And their use in E/R.