Professional Documents
Culture Documents
Kia Hyundai - Hệ thống smartkey
Kia Hyundai - Hệ thống smartkey
LOCK UNLOCK
▶ Limp Home for Engine Start / Khởi động khi có sự cố trong hệ thống
Kappa MPI 93
B_CAN B_CAN
C_CAN
FOB Holder Holder-less Type
SSB + Immo Coil
FOB max. 2ea FOB max. 3ea FOB + Card Key max. FOB + Card Key max.
* Acc. Fob 3ea 3ea
SRx (external Internal Receiver External Receiver Internal Receiver
receiver)
Kappa MPI 94
Engine ECU
ESC
Door handle
(passive SW & antenna)
Bumper Interior Smart key
antenna antenna Unit Smart key
Kappa MPI 95
E/R J/BOX
Relay Energized Signal
Vehicle Speed Relay Monitor signal
Hard Wire
ESCL Power
ESCL Ground
Unlock Switch
ESCL enable signal
Serial Comm.
LED control
C-CAN Gate way IMMO_ANT_power
IMMO_ANT_ground
RF Wireless Comm.
(433.92 MHz)
Serial Comm.
Kappa MPI 96
Chức năng
Glove Box
• Khởi động động cơ bằng nút bấm.
ụ ủ ệ ố - Antenna
Ăng ten bên trong xe 1 Ăng ten bên trong xe 2 (khoang hành lý)
Chức năng
Trên tay mở của của cửa trước
• Ăng ten LF kich hoạt tín hiệu
tìm chìa khóa cho SMK.
- Tìm chìa khóa bên ngoài xe - Tìm chìa khóa bên ngoài xe
tại khu vực cánh cửa. tại khu vực cốp sau.
Kappa MPI 98
PDM
ESCL comm. Serial interface
ESCL power
FET Power
ESCL ground Supply 2xhall sensor
FET
ESCL
Motor Steering Column
FET Lock/Unlock
ESCL Enable
Relay 1
Kappa MPI 99
2 5 6
3
8
4 9
Start
Stop
Button
B+
Smartkey
control
module
Function
• Điều khiển khóa điện thông minh, khởi động và tắt động cơ thông minh.
• Thông tin vị trí khóa điện bởi màu trên nút (Amber, red and white )
Kappa MPI 101
■ Hoạt động
LOCK UNLOCK
Kappa MPI 102
2
5
Door
Antenna
Passive
Lock 1 4
(Outside
Door
Unlock 6
Switch 3
■ Operation
■ Pre-Authentication
• Purpose : For starting engine quickly SMK unit searches the smart key and authentication is valid for 30 sec.
• Condition
: Every below case at the initial IG OFF state
- Door gets opened and closed,
- The brake or clutch pedal is pressed.
- key position changes from off to not-off.
Kappa MPI 104
SSB
4
Switch
Door
Antenna
Passive
Lock 1
(Outside handle)
3
5
2
Interior
Antenna
ụ ủ ệ ố - Key Reminder
■ Operation
1. Smart key is located inside the vehicle. (IG OFF)
2. Press door lock knob or central door lock button while any door is open.
3. All of doors get unlocked by BCM control.
• Purpose: Prevent door lock while smart key is inside.
※ In only EU area, when door is open, door locking is prevented by BCM.
(Regardless of the location of smart key.) And door lock knob is not applied.
Kappa MPI 106
ụ ủ ệ ố - Key Reminder
Interior
Antenna
3
Door
Lock
Actuator
Door 1
Switch
Door
Unlock 2
4
Switch
ụ ủ ệ ố - Welcome Light
B-CAN
SIGNAL
(HIGH)
Door
ANTENNA
PASSIVE
LOCK
SWITCH
(OUTSIDE HADLE)
ứ - Fail Safe
ể
ự ố ạ ộ ủ
ị
LED is NOT ON
Kappa MPI 112
Kappa MPI 113
ẩ – Failure cases
- Is the Smart Key the correct one that was learnt for the vehicle?
2 Passive lock or unlock is not engaged - Inspect the connector of the door handle
when the door handle button is - Inspect door antenna (by using GDS)
ẩ – Failure cases
4 Power mode changes when the button is pressed 2nd time. - Check that the SSB button signal is correctly inputted
ổ ợ
1. Main features
- Passive lock/unlock, passive engine start, ESCL, limp home
2. Main function
- key reminder, welcome light, door lock warning, fail safe
3. Diagnosis procedure
- DTC check
- Check symptoms in detail
- Predictive diagnosis
- Check the current data
- Analyze the circuit diagram
- inspect the components