Ans. Three 2. The respective BATT HOT warning light illuminates on the caution & warning panel(CAWP) ANS.-When the battery temperature exceeds 71 degree Celsius 3. The Battery hot caution light extinguishes when the temperature is ANS- Less than 63 degree Celsius 4. The starter/ generator temperature is sensed by ANS-Bimetallic temperature switch 5. The engine & APU starter/generator have similar construction but uses different brushes because ANS- The amount of cooling supplied & operating altitude 6. The DC external power is connected to the DC buses when a. Good external power is connected to the aircraft b. The battery master toggle switch on the DC control panel is set c. The EXT PWR toggle switch on the DC control panel is set ANS. d. ALL 7. The two galley load shed contactors are automatically closed when -The AC buses are energized by external AC power -when both AC generators are energizing AC bus -when AC generators are energizing their respective bus… 8. The speed of Q 400 aircraft is 667Km/h(360kts) 9. The “C” check of the DHC-8-400 aircraft is repeated every -6000 flight hours 10. The maximum towing angle of the nose gear is - 120 11. The flight data processing system (FDPS) makes the avionics caution light on the CAWP illuminate for no dispatch allowed avionics messages when -The aircraft is on ground & less than 50Knots….ANS. non dispatchable(non displaceable) 12. The two VHF transceivers are located -On the upper shelf of the avionics rack 13. The stand by control unit is tunes only VHF1 14. The ARINC communication & reporting system (ACARS) is used - For non- voice communication B/n the aircraft & ground station 15. The switch that sounds, a high/low chime sounds through the cabin & flight compartment speakers to check for correct speaker operation is done by … Ans .press to test switch on maintenance panel 16. Which system reduces the level of the periodic noise in the passenger cabin by the aircraft propeller ANS-The active noise & vibration control (ANVC) 17.In the AHRS if the TAS air speed is not available ANS- The attitude mode automatically changes to the degraded basic mode 18. The external protection system comprised of the following system ANS-Weather radar 19. The automatic direction finding (ADF) shows ANS.The magnetic bearing to a fixed non-directional beacon 20. The CDS is physically located in ANS-Input/output processorIOP1 21. The location of the standby pitot static probe is ANS.-On the right side of the FWD fuselage section 22. The marker beacons are navigation aids that transmit ANS.-A low power signal to mark an area above themselves 23. The very high frequency omni-range (VOR) ground stations from the victor airways navigation system, The VOR gives ANS.- Guidance on any track to/or from the station 24. The function of FMS is a. calculate the aircraft position & velocity b. Managing the aircraft flight path from origin to destination c. tuning communication & navigation ANS. d. ALL 25. The location of main & auxiliary battery is ANS- FWD nose on the left side,lower 26. “TOO LOW TERRAIN” aural alert sounds & PULL UP annunciator light comes on when -The air speed is less than 250Knote & above ground level altitude less than 750 feet (there are two choices with similar choices) 27. When the DME malfunction or the distance is out of range the numerical values for all indications changes to ANS- three white dashes 28. how many winding AC generator contactor has ANS.- two coil winding 29. The navigation page is shown on the -upper part of MFD 30. The armed FD mode is in white. When it changes to active mode it will be indicated by ANS.-reverse video, Black letters, on a green back ground When the VOR mode changes from armed to active, its indication is shown in ANS. reverse vedio - Black letters on a green background 32. The go around (GA) mode is usually to change ANS.- From approach to climb out flight condition for a missed approach 33. The function of IOP a. initialization b c d. all 34. In the PFD the vertical pointer is indicated - upper right hand attitude 35. The navigation page is normally displayed MFD1 & MFD2 36. If the auto pilot pitch trim is malfunction - A yellow indication will be displayed on PFD 37. In the FD the color of earth is - brown 38. If there is a fault in the genera tor the fault is sensed by -ACGCU 39. 125V ac…over voltage 40. External Ac power output Ans. Under frequency 370hz
41. If there is malfunction in the YD system disengages
Ans.- also disengages the AP 42. fd armed mode, ANS. waits for necessary conditions to fulfilled 43. The switch below LCD cooling filters to inhibit the cooling fan operation on ground when the temperature is … Ans. Below 5 degree centrigrade 44. GEN HOT caution light when temp…above 166 degree centigrade 45. If the GEN1 toggle switch is set to the OFF position …the generator out put ( GEN OUT) is supplied to ANS. Generator Reset 46. if The left TRU fails, the contactor which configures to connect secondary feeder buses A. k5 B.k6 c.k22…ans d.k26 47.If the Left TRU fails, the Left secondary feeder bus is powered by A.#1 DC generator B.#2 DC generator C. R TRU D.EBM?? 48.the Q4oo ignition system consists of A.exciter box B.ignition harness C.igniter plug D.all