Professional Documents
Culture Documents
Die Dynamic Buyoff Check Sheet For Air Cushion Dies
Die Dynamic Buyoff Check Sheet For Air Cushion Dies
,Pune
Die Dynamic Check sheet : - Draw Die
Part Name :
Die .No : Die name : Part.No :
OK -O,Not Ok - X, Not Applicable -NA
Trial 1 2 3 4 Final Tool Size : LR- X
Date FB- X SH- MM
M/c Tool Weight : Total-
Qty. Top-
Shut Height Die Maker :
6 Die location
7 Cushion stroke
8 Die clamping for upper tool
9 Die clamping for lower tool
10 B/H resting on cushion
11 Blank holder movement
12 W/P clearance BH to punch
13 W/P clearance die to BH
14 W/P Entry before contact with BH &die
14 Die face contact without blank
15 Tryout without B.B.Block
16 Blank position & size
17 Blank sagging
18 Testing panel at high C.P
19 Co-ordinate hole punching
20 Bottoming mark
21 Cushion above bolster
Trial
JBMMA/F/PE/37/01 Rev No:00 Date: 26.05.2018 Draw Die Dynamic Check Sheet Page : 1 of 2
Part No.
Op. No. OP. Name :
Tool Issues :
Status
Sr. No. Tool Issues DATE
T1 T2 T3 BUYOFF
JBMMA/F/PE/37/01 Rev No:00 Date: 26.05.2018 Draw Die Dynamic Check Sheet Page : 1 of 2
JBM Magnetto Pvt. Ltd.,Pune
Die Dynamic Check sheet : - Draw Die
Part Name
Part.No
Die .No Die Name
OK -O, Not Ok - X, Not Applicable -NA
Section Sr.No Check PointS What to be check T1 T2 Buy-off Remark
40 Shut height MM
Die Setting Parameter
41 Tons
Cushion pressure
42 Kg/CM sq
43 Counter balance pressure Kg /cm sq
44 Cushion stroke mm
45 Cushion above bolster mm
46 No of cushion pin qty
47 press speed spm
48 Press Used Tons
49 Required Tonnage Tons
C/L
BLANK LAYOUT
BLANK SIZE :
GRADE:
JBMMA/F/PE/37/01 Rev No:00 Date: 26.05.2018 Draw Die Dynamic Check Sheet Page : 2 of 2