Professional Documents
Culture Documents
DCC EGR 140 W Summer 2012 Final Exam
DCC EGR 140 W Summer 2012 Final Exam
SUMMER 2012
Page 1 of 8
1. Determine all components of reaction at the fixed support, O. The magnitude of M is 300
lbft. (50 points)
Page 2 of 8
2. Determine the force acting in cables AB, AC and AD for equilibrium. Free-body diagram of
ring A must be included and will be graded. (50 points)
Page 3 of 8
3. Determine the force in each member of the truss, and state if the members are in tension or
compression. (50 points)
Page 4 of 8
4. For the following beam assembly, (a) determine the reactions at pin supports C and E (50
points); (b) determine the internal loadings acting on the cross section at point G of the beam
(40 points).
Page 5 of 8
5. Draw the shear and moment diagrams for the overhang beam. On the diagrams, please
quantify the corresponding shear force values and bending moment values at locations A, B,
and C. (60 points)
Page 6 of 8
6. If the vending machine has a weight of 300 lb, and the static frictional coefficient between
the vending machine and the surface of the truck-bed is s = 0.8, determine the maximum
angle that the surface can be raised without causing motion of the drum. (Hint: you must
consider both sliding and tipping over.) (50 points)
Page 7 of 8
7. Locate the centroidal position, , of the sectional area, and then determine the moment of
inertia of the area about the centroidal x axis. Neglect the small overlapping of the circles
and the rod. (50 points)
Page 8 of 8