Professional Documents
Culture Documents
th
Page 1 of 2 Revision : 00 Revision Date : 13 Feb, 2012
NOVATEX LIMITED SOP / E&I / 96
1 PURPOSE:
To remove / install break out box to the servo valve
2 SCOPE:
Electrical & Instrument Department (YES)
Moulding Process (YES)
Safety ( NO)
3 PRE-REQUISITE
Approved cold work permit
Proper tools
4 PROCEDURE:
Generate a cold work permit according to the job
Motor must be electrically isolate
Remove the electrical connector from the servo valve
Attach the breakout box connector (which is to be install) to the servo valve and the servo valve
cable to the breakout box
Make sure that breakout box is accessible from outside of the gates
Attach its multimeter to the break out box
For removing the break out box, remove its multimeter
Then remove the male end of the breakout box connector to the servo valve and the female end to
the servo valve cable
Then reconnect the servo valve cable to the servo valve
After completion of job, close your work permit from concerned authorized personnel
Clean the area & remove all the tools
Make an entry of the said job in the technician log book
5 RELATED DOCUMENT:
Control of Monitoring & Measuring Devices ISP / MR / 06
Process Control Maintenance MOP / E&I / 16
Work permit procedure
6 RECORD:
Technician Log Book E&I / R10
th
Page 2 of 2 Revision : 00 Revision Date : 13 Feb, 2012