Professional Documents
Culture Documents
Assignment/Homework-II
Date of release- October 1, 2020 Date of submission- 9 October 2020, 17:00 hrs Late submission
will not earn any credit and will be considered to be no-submission
P-1: The SCR shown has the latching current of 20mA and is fired by the pulse of width 50µs.
Determine whether the SCR triggers or not.
P-2: A SCR is connected in series with a 0.5H inductor and 20Ω resistance. A 100V DC voltage is
applied to this circuit. If the latching current is 4mA, find the minimum width of the gate trigger pulse
required to properly turn-on the SCR.
P- 3: A SCR has a linearized gate-cathode characteristic of slope 25 V/A. A gate current of 200mA
turns the thyristor on in 16µs. The gate source voltage is 10V. The manufacturer’s average maximum
power for the gate is 400mW. Pulse firing is used.
Calculate: (a) the value of the gate series resistance; (b) the gate power dissipation during turn-on; and
(c) the frequency of the gate pulses.
P- 4: The range of spread of gate-cathode characteristics for a certain thyristor can be linearized to
between 15V/A and 10V/A. The manufacturer's data gives the maximum gate power dissipation as
5W. Sketch the characteristic up to Vcc = 15V and Ic =1.5A, and insert the PG(max av) line. With the
gate firing circuit as shown in Fig. aside, a 1:1 isolating transformer, Vp amplitude of 20V, and Rl =
R2 = 20Ω, determine the possible range of VGC
P-5: In the single-phase half-wave rectifier shown below, assume that the load current Ia is constant
(load inductance L i s very large).
(a) Sketch waveforms of the load voltage v 0 and the thyristor current i T for α = 60°. ( b) Find the
average power supplied to the load Pav as a function of the firing angle α. (c) The thyristor has a
constant voltage of VT =1.2 V across it when it conducts. Find the average power dissipated by the
thyristor for α = 90°.
P-6: A single-phase fully-controlled bridge converter supplies power to a highly-inductive load with
resistance. R= 10Ω from a 240 V rms 50 Hz AC source, as shown below. (a) Find the firing angle α
so that the average power supplied to the load is Pa v = 1200 W. (b) For α = π/6 find the input power
factor of the rectifier.