Professional Documents
Culture Documents
1.4 Carry out safety check of the flight compartment for proper position of the control.
1.6 Review the A/C technical log book and PFR and take corrective actions as necessary.
ALL 1.7 IF ECAM ENG OIL QTY LOW LEVEL advisories are reported.
Check engine oil quantity ( ECAM LOWER DISPLAY ENGINE PAGE) with 30 minutes
after engine shut-down :
if indication is below minimum , check engine oil level at tank sight- glass to top-up as
requierd with oil and record uplifes in technical log book
DAILY PAGE: 3 of 6
AFT FUSELAGE
Visual chech aft fuselage for general condition , including :
. Antennas ang beacon
11 to 15 2.9 . Fresh water drain and waste water draine mast .
. Service panel and door .
. Outflow valve : no obstruction .
. Fuselage tail skide for damage of ground contact during take off .
CHAM WINGS AIRLINES
DAILY PAGE: 4 of 6
4.0 WHEELS
Check pressure of the tires ( refer to the table below ), and record the
4.1
values:
Remove the
Inflate to Remove both Tires If one
A/C TYPE tire if pressure
Nominal range. tire less than
A-320 –212 less than
215± 5( PSI) 161 (PSI)
MTOW 77000 kg 181 (PSI)
CAUTION: Tire pressure must be checked and corrected, whenever possible, when
the tires are cold. Service with NITROGEN only. AMM task ( 32-41-00-210-003).
CHAM WINGS AIRLINES
DAILY PAGE: 5 of 6
5.2 Check the windshield, slide and fixed windows for damage and cleanliness.
5.4 Check and replace spare bulbs / fuses if any are missing.
DAILY PAGE: 6 of 6
CERTIFICATION
I hereby certify that the maintenance work specified above has been carried out in accordance with SCAR , Manufacturer’s
documents and the aircraft is fit for release to service.
NOTE: A signature in the " AUTH " column certifiies that task has been Carried out to the
standard required for the issue of a CERTIFICATE of Release to SERVICE