Professional Documents
Culture Documents
PAGE
1.0 INTRODUCTION 2
1.0 INTRODUCTION
The method statement provides a methodology for the installation of brackets for
the proposed smoke curtain system.
It shall consist of
b) Construction Stage
3. Tools, e.g. powered hand - Check hand tools and equipment are
tools, step ladders, etc. in good working conditions.
Content Procedure
1. Smoke curtain’s bracket - Mark and set out smoke curtain’s
installation brackets that exposed ceiling.
- Cut ceiling to access, install new
bracket and remove the exposed
bracket.
- Measure brackets length required.
- Fabricate brackets to suit in the ceiling
- level.
Install bracket and adjust the bracket
- level.
- Tighten the screw.
- Cut the exposed bracket and remove it.
- Patch and plaster the opening ceiling.
- Clean and do housekeeping work area
before leave site.
The following is the procedure for the smoke curtain system installation.
1. Set out and mark smoke curtain’s brackets that exposed ceiling.
2. Cut ceiling around bracket to access.
3. Measure bracket length required.
4. Fabricate brackets to suit in the ceiling level.
5. Install bracket and adjust the level.
6. Tighten the screws.
7. Cut the exposed bracket and remove it.
8. Patch and plaster the opening ceiling.
9. Clean and do housekeeping at work area before leave site.