Professional Documents
Culture Documents
2021
A. What’s New?
The Polyvinyl Chloride (PVC) rigid conduit is one of the most popularly used
electrical tubing in electrical wiring installation today. Because of its versatility you
can easily make any bends that will fit to the requirements.
When making bends on PVC conduit, the electrician should consider the
internal diameter of the conduit is not diminished or weakened in such a way that
the ability of the conduit to accommodate its maximum number of conductors and
pulling of conductors would be much easier.
B. What Is It?
DSK-CID-LRMS-LAS-v1r0.0e03.09.21
Serbisyong may Integridad, Kalidad, Angat, at Tapat
Equipment:
1. Heat gun
Materials:
1. Pencil or chalk
2. PVC pipe
DSK-CID-LRMS-LAS-v1r0.0e03.09.21
Serbisyong may Integridad, Kalidad, Angat, at Tapat
Direction: Draw to the box below a right-angle guide for bending 90° Elbow
Bend. Use proper instruments for this drawing activity.
Picture
232 ...
Picture
235 ...
Picture
234 ...
233
Accomplished
Following All Followed most Followed None of the
Project directions directions some directions
Directions were directions were
followed. followed.
Use of You need You used your You used You did not
Creativity your own ideas most of some use your
ideas and the time imagination own ideas or
imaginatio imagination
n
Effort You took You worked You put a You rushed
your time hard most of the small effort through and
and worked time into the did not work
hard on the project hard.
drawing
E. References
DSK-CID-LRMS-LAS-v1r0.0e03.09.21
Serbisyong may Integridad, Kalidad, Angat, at Tapat