You are on page 1of 1

39000

X
2900 1300 3300 2500 5800 1200 7400 500 6700 4800 1700 NOTES

16000
GENERAL
All dimensions are in mm unless otherwise specified.
Drawing are not to scalled. only figured dimensions to be used

The contractor must check and verify all dimensions before


commencement of any work. Any discrepancies to be clarified
with the Project Architect.

CONSTRUCTION

12300
All slab at ground level to be cast over 1000 guage polythene
sheet on 50mm thick murram blinding on hardcore.

10,408
15800

8,644
All soil under slab around and under foundation to be treated

7500
for termite control.

4000
CIVIL

All soil on cut embararkment to be stablized.The slope not to


exceed 45 degree.

STRUCTURAL
14800

All black cotton soil to be removed from all buildings and paved
surfaces

For all R.C work,refer to stuctural Engineer's details.


Tensile fabricSection X-X Scale 1:100 Depth of foundation to be detemined on site to S.E's aproval

All walls to be reinforced with loop iron at every


D- 01 every alternate course.
16600
End cap D-01 Steel mast
All adjacent R.C. work and masonry walls to be tied with loop iron
at every alternate course.

MECHANICAL
Mast Eye end bolted to pylon flange
Tensioner guy to base All plumbing and drainage to comply with relevant local authority
SVP denotes soil vent pipe to be provided at the head of the
Heavy duty STL clevis connector bolted to pylon flange drainage system

12800
Catenary cable Drains pass beneath buildings & driveways to be encased in
Steel plate 150mm concrete surround.

The storm drain pipes to comply with BS 556 specification.


Fabric membrane All underground foul and waste drain pipes shall be uPVC to
Internally threaded clevis bolted to plate comply with BS 5255.
All inspection chambers covers and framing shall be cast iron.
16200
Minimum slope in the drains pipes to be 1 in 100
Transioner cord
No chases will be allowed for pipes. Sleeves will be allowed with
written approval of structural Eng's. No cutting of concrete without
8700

Fabric membrane express approval of the Architect or structural Eng.

The back cable All testing of pipes must be completed before plastering.
Open swage socket D- 02 All mechnical works must be co-odinated with electrical and any
conflict must be clarified before work begin.
and turnbuckle
PV denotes permanent ventilation
1340
0

ELECTRICALS
All conduits must be laid before plastering

15500
00

REVISI0NS
62

13,030 Pin and anchor base


plate
anchor bolts

RC to SE details
X

Tensile fabric Plan Scale 1:100


Tensile fabric fitting detail Scale 1:10

1500mm high 150x150 18mm 12mm Thick plaster finished Tensile fabric mast detail Scale 1:10
thick stainless steel angle with 3-coats of water proof
protection paint to approval
section painted to approval Project Title

precast concrete coping tiles


80

PROPOSED CONSTRUCTION OF
complete with drips D-02 MARIIRA FARM AGRICULTURAL RESEARCH CENTER

200mm thick
masonry wall laid in v joints in plaster
Drawing title
courses mortar joint
Metal plate
1,300

not exceeding 3coats asphalt waterproofing


200mm membrane laid to approval WORKING DRAWINGS

Membrane Pylon flinge


3 degrees Water discharge pipe with
sloping floor metal grating filter to ME
details
sttepped DPC
400

Client
MURANGA COUNTY GOVERNMENT
turned down and
sealed to water
150

proofing
SCALE: DATE
AS SHOWN DEC 2022
Water discharge
downpipe Name Signature
into sewer duct
screwed and
plugged to RC Drawn ARCH NDIRANDU
DANIEL
column and
18 18 painted to
150 350 150 approval 300x300RC column to SE details Design
County Architect
400mm thk masonry walling

600 CWO KFI

column part plan detail scale


1:5 parapet wall detail scale1:20 SHEET NO:
Bolt rope DEPARTMENT OF ROADS,TRANSPORT
& PUBLIC WORKS
COUNTY GOVERMENT OF MURANGA ONE

200mm thick masonry wall with


12mm thick plaster finished as
Bolt
per schedule..

150x20mm Quarry tile skirting


from an approved supplier jointed
and pointed in cement mortar on
prepared backing to approval.
1000Gauge damp-proof
membrane laid to approval. Tensile fabric fitting detail Scale 1:10
8m m thick non slip ceramic floor tiles on
32mm thick 1:2 (cement :sand)
1,800 screed laid to approval.

300x300mm non -slip heavy duty


concrete tiles patterned to
B3

approval.

100mm thick r .c pedestrian w alk


600

sloped to drain. 'Umbrella ' fire


extinguishing sprinkler
200

'Pyroc' sprayed ceiling


finish on the underside system . Pipe sizes to
to approval. M.E 's detail.
Terrazzo finished
7
6
5
4
3
2
1

50x50mm two coat


Mastic asphalt angle treads and risers.
fillet.
T =300mm R =
300mm deep hardcore well
23R x 157
UP

compacted to approval.
150mm
22G x311
B4 B4
8
300mm thick reinforced 9
ribbed structural floor slab.
Reinforcement details to
RET AINED EARTH S.E 's details.
BASEMENT 2 FLOOR
- 6600 LEVEL 10
11
LIFT
5,050

50x50mm tw o coat
Mastic asphalt angle
'Umbrella ' fire
extinguishing sprinkler
system . Pipe sizes to
SERVICE
M.E 's detail. 12
LIFT
150mm thick masonry protective fillet.
walling finished w ith 12mm thick
plaster and 3-coats water-proofing
paint to approval. 13

12mm thick plaster on protective


14 Polished terrazzo
masonry walling finished w ith 3_coats
of water-proof paint to approval.
15 floor finish on stair
landing
3-coats 20mm thick mastic
16
asphalt tanking applied to rough 400x600mm R .C column with a
concrete face to approval. 1500mm high iron angle
protection .
30mm thick cement /sand grout.
30x12 thick
DOWN 23

150mm thick r .c loading slab


200mm thick r .c w alling
to S.E 's details.
ribbed to approval. Reinforcement
layout to S.E 's details.
carborendum non-slip
BASEMENT 1 FLOOR
- 3600LEVEL
strips to approval.
50x50mm mastic angle 50mm thick protective
17
18
19
20
21
22

fillet . screed.
200

3-coats of 30mm thick


B3

75mm thick coarse horizontal Mastic asphalt


clinker blinding . applied over concrete base to
approval.
60mm thk 1000mm
high timber finish
hand rail
Basement part section detail scale:120
Main Stair Plan 1 : 20
6 200 6
150mm loading slab ribbed
20 solar
20mm
to approval. Reinforcement
bronze Tinted
layout to S.E 's details. glass Finish as per schedule Finish as per schedule
mezanin
e floor + 3600
450mm deep r.c beam to +3600mezzanine
floor
R.C beam to. S'E s detail r.c beam to.E'sS detail

S.E .'s details


25 50 12

5025 12

31

25x33mm
mm z section steel
10

75x50mm camphor wood casement sash framing


casement sash framing
25

12 230 50 120 12
6mm
mm peripheral fogged
6mm peripheral fogged clear glass in glass putty
clear glass in glass putty as per schedule
.
60mm thk as per schedule
.
1000mm 60mm thk1000mm 6 105 12 25 52 5 6
hardwood profiled hardwood profiled 6 200 6
handrail with handrail with
with30x6metal
212
30x6 metal section flat core
- rail
12mm
mm thk finish as
section flat core- per schedule
rail 30 12thick
30x 25x33mm
mm z section steel
carborendum non -slip Outer jamb finish to detail casement sash framing
strips to approval
.
6

MashrabiyaStair opening 125 x25mm thick camphor 250x80mm


mm bevelled precast
to schedule 30x12 thick window board painted concrete Sill to' SE s.detail
to approval
.
carborendum non-slip
115

strips to approval. Masonry walling


20

20 mm quadrant timber bead Cement/sand jointing


.
20

- 0 ground
+ floor Wall finish as per schedule
.
50
40

ground 7 10
floor 0-+ 150mm loading slab ribbed
10 6 105 95 12 15 10x10mm
mm drip mould
.
6mm
mm clear glass in glass
60

400 mm thk Masonry walling


; putty as per schedule
.
to approval. Reinforcement 150
150mm loading slab ribbed See plan
.
layout to S.E 's details. to approval . Reinforcement
6

layout to ..E'
S E' s details
. 15 5 12
Window Sill. line

Section B 3 - B 3 1 : 50 Section B 4 -B 4 1 : 50

Window Detail 1 :5

GSPublisherVersion 0.50.100.100

You might also like