You are on page 1of 14

Materials System Specification 18 November 2021

17-SAMSS-503
Severe-Duty, Totally Enclosed, Squirrel Cage Induction
Motors to 500 HP
Document Responsibility: Motors and Generators Standards Committee

Previous Revision: 29 October 2018 Next Revision: 18 November 2026


Contact: (dabbourm) Page 1 of 14
© Saudi Arabian Oil Company, 2021

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Contents
SUMMARY OF CHANGES ........................................................................................................................ 3
1 SCOPE ............................................................................................................................................... 4
2 CONFLICTS AND DEVIATIONS ....................................................................................................... 4
3 REFERENCES ................................................................................................................................... 4
4 QUALIFICATION ................................................................................................................................ 5
5 MODIFICATIONS TO INDUSTRY STANDARD (IEEE 841) ............................................................. 6
6 MODIFICATIONS TO INDUSTRY STANDARD (IOGP S-703) ......................................................... 8
DOCUMENT HISTORY ........................................................................................................................... 11

© Saudi Arabian Oil Company, 2021 Page 2 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Summary of Changes

Paragraph Number Change Type


(Addition, Modification, Deletion, Technical Change(s)
Previous Revision Current Revision New)
(29 October 2018) (18 November 2021)
- Motors rated above
1kV shall be specified
to IEEE 841.
1 1 Modification
- Motors rated up to
1kV shall be specified
to IOGP S-703.
Added IOGP S-703D
Data Sheet for Low
3.1 3.1 Addition
Voltage Three Phase
Cage Induction motors.
Added the standard
3.2 3.2 Addition
IOGP S-703.
Added IEC 60034 to the
4 4 Modification
qualification paragraph.
Replaced “agency” with
5/1.3 5/1.3 Modification “certifier/certification
body”.
The required Motor
5/4.3 5/4.3 Modification voltage rating is above
1kV.
5/4.3 5/4.3 Deletion Note 1 and 3 are deleted.
Motors (high voltage)
under the scope of IEEE
5/11.1 5/11.1 Modification
841 shall have space
heaters.
Motors rated less than
5/11.2 - Deletion 100HP are specified to
IOGP S-703 (Section 6).
A new section for the
NA 6 Addition modification of IOGP S-
703.
Modified IOGP S-703
NA modified B Addition
Datasheet

© Saudi Arabian Oil Company, 2021 Page 3 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

1 Scope
This Specification, together with the Data Sheets, defines the mandatory
requirements for totally enclosed squirrel cage induction motors rated from 0.75
kW (1 HP) to and including 370 kW (500 HP). Specifications of machines rated
above 1 kV shall comply with Section 5 of this Specification (Modifications to
Industry Standard IEEE 841). Otherwise, machines’ specifications shall comply
with Section 6 (Modifications to Industry Standard IOGP-S-703). Unless
otherwise specified, sections in this specification do not apply to explosion proof
motors.
2 Conflicts and Deviations
Any conflicts between this document and other applicable Mandatory Saudi
Aramco Engineering Requirements (MSAERs) shall be addressed to the
EK&RD Coordinator.
Any deviation from the requirements herein shall follow internal company
procedure SAEP-302.
3 References
All referenced specifications, standards, codes, drawings, and similar material
are considered part of this Material System Specification to the extent specified,
applying the latest version, unless otherwise stated.
3.1 Saudi Aramco References
Saudi Aramco Engineering Procedure
SAEP-302 Waiver of a Mandatory Saudi Aramco
Engineering Requirement
Saudi Aramco Inspection Requirements
Form 175-170200 Severe Duty Totally Enclosed Squirrel Cage
Induction Motors to 500 HP
Saudi Aramco Datasheets
SA-2861 IOGP S-703D Data Sheet for Low Voltage
Three Phase Cage Induction Motors
3.2 Industry Codes and Standards
Institute of Electrical and Electronics Engineers, Inc.
IEEE 841 Standard for Petroleum and Chemical
Industry-Premium Efficiency, Severe Duty
Totally Enclosed Fan-Cooled (TEFC) Squirrel

© Saudi Arabian Oil Company, 2021 Page 4 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Cage Induction Motors - Up to and Including


370 kW 500 HP
International Association of Oil & Gas Producers
IOGP S-703 Supplementary Specification to IEC 60034-1
Low Voltage Three Phase Cage Induction
Motors
International Electrotechnical Commission
IEC 60034 Rotating Electric Machines
IEC 60072 Dimensions and Output Series for Rotating
Electrical Machines
IEC 60079 Electrical Apparatus for Explosive Gas
Atmospheres International Organization for
Standardization
ISO 3744 Acoustics - Determination of Sound Power
Levels of Noise Sources Using Sound
Pressure
National Electrical Manufacturers Association
NEMA MG-1 Motors and Generators
National Fire Protection Association
NFPA 70 National Electrical Code (NEC)
Underwriters Laboratories, Inc.
UL 674 Electric Motors and Generators for Use in
Division 1 Hazardous (Classified) Locations
4 Qualification
Induction motors shall be supplied by Vendor qualified by experience in
manufacturing the units proposed, approved by Saudi Aramco, and listed in the
RVL (Regulated Vendors List). To qualify, the Vendor or his licensee must have
manufactured at the proposed location of manufacture at least 2 units with
identical or higher performance characteristics (speed, power, voltage,
enclosure/cooling) and at least 100 motors meeting the requirements of IEEE
841 or IEC 60034. These motors must have been in service for at least 3 years
and must be performing satisfactorily. Details and location of operation shall be
provided to Saudi Aramco upon request. In addition, the vendor shall disclose
each proposed design, manufacturing procedure, component, or assembly that
does not have at least 2 years satisfactory field operating experience in similar
service.
© Saudi Arabian Oil Company, 2021 Page 5 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Exception:
Induction motors may be supplied by a local motor vendor subsidiary that has the capability to
manufacture in-kingdom a complete motor (stator, rotor, frame) based on the parent company’s
proven design, with a complete 3-year standard warranty. The motors shall be fully tested in-
kingdom at the local vendor’s site as per Saudi Aramco specification requirements. The
manufacturer’s proven design must have been previously manufactured at an approved plant
location and adhere to the above Qualification requirements.
5 Modifications to Industry Standard (IEEE 841)
The following clause numbers refer to IEEE 841 - 2009, which is part of this
Specification. The text in each clause below is an addition to IEEE 841 unless it
is noted as an exception. Clause numbers not appearing in IEEE 841 are new
clauses to be inserted in numerical order. Clause numbers appearing in IEEE
841 that are not modified are not repeated in this specification.
1 Overview
1.1 Scope
1.1.1 (Exception) Fractional horsepower, non-explosion proof, shall comply
with NEMA MG 1 or IEC 60034.
(Exception) IEC 60072 series may be used for dimensions and output.
1.3 Explosion Proof Motors
Where explosion proof construction is specified or required because of
the area classification, the motor shall meet either the Underwriters
Laboratories (UL) listing requirements of UL 674 or equivalent. Motors
for use in Class I or II, Zone 1, hazardous locations as defined by
ANSI/NFPA 70, or IEC-60079, shall be certified by a third-
partycertifier/certification body. Explosion proof motors do not have to
conform to the requirements specified in this document, except for the
testing requirements of IEEE 841, Section 9.
1.4 Motors for Class 1, Zone 2 Locations
Motors specified for Class 1, Zone 2 hazardous locations shall meet
ANSI/NFPA 70, or IEC-60079, requirements for this application.
Unless the space heaters are approved for Class 1, Zone 2 locations, the
temperature exposed surfaces of space heaters (based upon a 50°C
ambient) shall not exceed 80% of the ignition temperature in °C of the
gas or vapor involved when operated at the specified voltage.
1.5 Inspection Requirements
Refer to Saudi Aramco Inspection Requirement Form 175-170200, for
inspection requirements.

© Saudi Arabian Oil Company, 2021 Page 6 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

3 Service Conditions
3.2 Unusual Service Conditions
Unless otherwise specified, motors conforming to this specification shall
be suitable for operation in accordance with their rating while exposed to
ambient temperatures in the range of 0°C to 50°C.
4 Ratings
4.2 Frame Assignment
(Exception) Motors' frame sizes shall comply with NEMA MG-1 or
IEC-60072.
4.3 Voltage and Frequency Ratings
(Exception) Motors supplied under this specification shall comply with the
following table:

Motor Voltage Rating Motor HP Rating


Above 1kV(note 1) 185kW (250 HP) to 370kW (500 HP)
Note: 1-The motor shall be capable of starting and accelerating the driven load to operating
speed with 80% of the rated voltage at the motor terminals without stalling or exceeding
its thermal capability. Purchaser will provide load speed vs. torque curve and load Wk²
when motor is purchased separately from driven equipment. (Refer to SAES-P-113 for
the voltage selection criteria)
Exception:
The rated voltage of motors which are part of an Adjustable-Speed Drive system shall
be at the discretion of the drive system supplier.
4.5 Enclosures
Motors shall be fitted with replaceable shaft seals of the non-contacting
while rotating type. Seals shall be fitted on both the drive end and non-
drive end of the shaft.
5 Electrical Performance
5.1 General
Motor electrical performance and characteristics shall be in accordance
with NEMA MG 1 or IEC-60034.
5.4.2 The maximum total temperature shall not exceed 120°C.
6 Mechanical Features
6.1 Bearings and Lubrication

© Saudi Arabian Oil Company, 2021 Page 7 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

c) Conrad deep-groove or spherical roller thrust bearings are


required for vertical flange-mounted motors with thrust loading.
d) For vertical motors which are designed for external thrust loads,
the thrust bearings shall also be rated for an L-10 minimum life of
5000 hours continuous service at 200% of the maximum (during
operation at rated capacity, stopping, or starting) specified up and
down thrust.
g) The grease shall be made with a synthetic polyurea thickener and
a highly refined mineral oil and contain a high level of inhibitors to
protect against moisture and salt water contamination.
6.3 Frames, End-shields, and Fan Covers
d) Alternatively, the tolerances identified in IEC 60072-1, for foot
flatness, may be used.
6.4 Fans
(Exception) Unless otherwise specified, fans shall be made of conductive
plastic for 4-pole or higher motors up to 250hp
6.8 Airborne Sound
a) Sound power level shall be determined in accordance with either
NEMA MG 1 or ISO 3744.
11 Space Heaters
11 c (Exception) unless otherwise specified, the space heater rated voltage
shall be 230 V.
11.1 Motors shall be equipped with space heaters.
11.3 If space heaters are provided, a caution nameplate per paragraph 10.2
shall be provided stating CAUTION: SPACE HEATERS MAY BE
ENERGIZED.
6 Modifications to Industry Standard (IOGP S-703)
The following clause numbers refer to the Supplementary Specification to IOGP
S-703 Low Voltage Three Phase Cage Induction Motors, which is based on IEC
60034-1 and is part of this Specification. The text in each clause below is an
addition to IOGP S-703 unless it is noted as an exception. Clause numbers not
appearing in IOGP S-703 are new clauses to be inserted in numerical order.
Clause numbers appearing in IOGP S-703 that are not modified are not
repeated in this specification.

© Saudi Arabian Oil Company, 2021 Page 8 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Introduction
Exception: replace (IOGP S-703D) with Saudi Aramco customized data sheet
(IOGP S-703D-Aramco).
Exception: replace (IOGP S-703Q) with Saudi Aramco customized quality
requirements (IOGP S-703Q-Aramco).
Exception: delete “The data sheet and IRS are published as editable
documents for the purchaser to specify application specific requirements. This
supplementary specification and the QRS are fixed documents.”
Exception: delete “The order of precedence (highest authority listed first) of the
documents shall be:”
1 Scope
1.2 Exception: non-explosion proof motors less than 746 W (fractional
horsepower) shall comply with NEMA MG 1 or IEC 60034.
1.4 Exception: delete section 1.4
6 Site conditions
Addition: Unless otherwise specified, motors conforming to this
specification shall be suitable for operation in accordance with their
rating while exposed to ambient temperatures in the range of 0°C to
50°C.
8 Thermal performance and tests
8.1 Thermal class
Exception: For motors at 50°C ambient temperature, the maximum
temperature rise shall not exceed 70°C for class F insulation.
9.12.1 Starting
9.12.1.3 Addition: Purchaser will provide load speed vs. torque curve and
load Wk² when motor is purchased separately from driven
equipment.
11.3.2 Rotor
11.3.2.2 Exception: Maximum vibration magnitude shall be in accordance
to Vibration Grade B.
11.3.2.4 Addition: Motors shall be fitted with replaceable shaft seals of the
non-contacting while rotating type. Seals shall be fitted on both
the drive end and non-drive end of the shaft.
11.3.5 Bearings

© Saudi Arabian Oil Company, 2021 Page 9 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

11.3.5.1 Addition: The grease shall be made with a synthetic polyurea


thickener and a highly refined mineral oil and contain a high level
of inhibitors to protect against moisture and salt water
contamination.
11.3.5.5 Vibration monitoring for bearings is not required.
11.3.5.7 Addition:
a. Conrad deep-groove or spherical roller thrust bearings are
required for vertical flange-mounted motors with thrust
loading.
b. For vertical motors which are designed for external thrust
loads,
the thrust bearings shall also be rated for an L-10 minimum
life of 5000 hours continuous service at 200% of the
maximum (during operation at rated capacity, stopping, or
starting) specified up and down thrust.
11.3.6 Space heaters
11.3.6.1 Exception:
a. Motors rated 75 kW (100 HP) and above shall be equipped
with space heaters.
b. Motors less than 75 kW (100 HP) shall be equipped with
space heaters if specified in Data Schedule 1.
11.3.6.2 Exception: Unless otherwise specified, the space heater rated
voltage shall be 230 V.
11.7 Temperature monitoring
11.7.1 Temperature monitoring is not required.15 Motors intended for use in
potentially explosive atmospheres
15.1.1 Addition: Increased safety type motors shall not be used in Zone 1
classified areas.
15.1.2 Addition: Unless the space heaters are approved for Class 1,
Zone 2 locations, the temperature exposed surfaces of space
heaters (based upon a 50°C ambient) shall not exceed 80% of the
ignition temperature in °C of the gas or vapor involved when
operated at the specified voltage.

© Saudi Arabian Oil Company, 2021 Page 10 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Document History
18 November 2021 Major revision to overlay this specification on IOGP S-703 for
motors rated at 1 kV or below, and IEEE 841 on motors rated
above 1 kV.
29 October 2018 Major revision to:
• Address the qualifications requirements for suppliers, which is
becoming less strict, in alignment with the most major
commodities.
• Allow motors in the range of 250HP to 500HP to be either 460V
or 4kV.
• Mandate nonmetallic for the motor internal fans.
8 April 2018 Major revision regarding:
• Local vendor manufacturer qualification.
• Rated voltage level options for 250-500 HP motors.
• Fan material to be made of conductive plastic.
8 March 2016 Minor revision to align rated voltage requirement of 17-SAMSS-
503 with SAES-P-113.
• To align temperature rise requirement of 17-SAMSS-503 with
SAES-P-113.
• To remove the overlap between 17-SAMSS-503 and 17-
SAMSS-502 at the 500 HP size. This will enhance clarity and
align the two SAMSS.
• To align the space heater voltage with the available SAES-P-100
standard voltages.

26 October 2015 Major revision that includes reducing the risks of electric shock
upon Motors Maintenance personal due to energized space
heaters, updating the standard to be in-line with the industry
current IEEE 841-2009 new standard, and aligning with SAES-P-
100 (Basic Power System Design Criteria) voltage levels.

© Saudi Arabian Oil Company, 2021 Page 11 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

A. Modified IEEE-841 Data Sheet

1. APPLICABLE TO: [ ] Inquiry [ ] Proposal [ ] Purchase [ ] As Built


2. Plant: _____________ Plant No. __________ Driven Equipment: ___________________
3.
4. Purchaser's Data to Be Supplied With Inquiry:
5.
6. BASIC DATA:
7. Volts: _________ Phase: 3 Hertz: 60 Nameplate: _________kW ________HP
8. Full Load RPM: _________ Speed Range for Variable Speed Drive:_______________
9. Rotation When Facing Motor Opposite Drive End:
10. [ ] Clockwise [ ] Counter-Clockwise [ ] Bi-Directional
11. Motor Thrust Loads: [ ] None [ ] Other (specify) ________________________________
12. Type Load: [ ] Direct Coupled [ ] Belt Driven [ ] Other_______________________
13. NEMA Torque Design: [ ] "B" (normal) [ ] Other (specify)______________________
14.
15. SITE DATA:
16. Site average temperature: ______°C
17 Area Classification: [ ] Non-Hazardous
18. [ ] Hazardous (Classified) Class: _____ Group: ______ Zone: ______
19. Ignition Temperature: ______°C
20. Elevation (Specify if Above 1000 m.): ________m.
21.
22. STARTING:
23. [ ] Full Voltage [ ] Reduced Voltage % and Type______________________________
24. [ ] Adjustable Frequency Drive Unit Type______________________________________
25. [ ] AFD Details Attached (If motor purchased separately from drive unit.)
26.
27. MOUNTING:
28. [ ] Horizontal [ ] Vertical Shaft Up [ ] Vertical Shaft Down
29. [ ] Foot Mounted [ ] Flange Mounted, NEMA Type______________________________
30.
31. ENCLOSURE:
32. [ ] TEFC [ ] TENV [ ] Explosion Proof [ ] Other___________________________
33. Main Terminal Box Conduit Hub Size:_________ in.
34.
35. Space Heaters:
(1)
36. [ ] Space Heater Required for motors rated less than 75kW (100HP)
37.
38. Heater Leads: [ ] Main Terminal Box [ ] Separate Heater Terminal Box

(1) Note to Purchaser: It may not be possible for some manufacturers to accommodate this requirement because of space
constraints. Also, since these motors are generally mass produced, requiring space heaters may delay delivery and add
cost. Space heaters are required for 75 kW (100 HP) & above.

BI/JO No. _______________________________


PO/RFQ No.________________L/I No.________
Data Sheet Page 1 of 2 By: _____________
Date _________________ Revision _________

© Saudi Arabian Oil Company, 2021 Page 12 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

Modified IEEE-841 Data Sheet (Cont'd.)

1. Vendor Data:
2.
3. GENERAL INFORMATION
4. Manufacturer______________ Model____________ Serial No.____________ Tag No _______
5.
6. MOTOR DATA
7. Rating Data at 1.0 Service Factor:
8. Nameplate Power________kW (HP) Voltage_______ Phase_______ Hertz_________
9. Full Load Speed___________RPM Enclosure Type__________ Frame Size_________
10. Rotation When Facing Motor Opposite Drive End:
11. [ ] Clockwise [ ] Counter-Clockwise [ ] Bi-Directional
12.
13. Torque:
14. Speed-Torque Curve No._____________ Speed-Current Curve No.________________
15.
16. Design Data at 1.0 Service Factor and Rated Voltage:
17. No Load Current __________________Amps
18. Load 25% 50% 75% Full
19. Amperes _______ _______ _______ _______
20. Power Factor _______ _______ _______ _______
21. Nominal Efficiency _______ _______ _______ _______
22. Guaranteed Efficiency _______ _______ _______ _______
23.
24. Locked Rotor Amps at Rated Voltage_________
25.
26. Insulation System:
27. Class________ Temperature Rise_______°C above _______°C ambient at 1.0 SF
28.
29. Bearing Information:
30. Coupling End Bearing: Manufacturer's Type____________ Part No.____________
31. Outboard End Bearing: Manufacturer's Type____________ Part No.____________
32.
33. Certification: Class______ Group_______ Zone_______ Agency__________
34.
35. Weights/Dimensions:
36. Net Weight_________kg Rotor Weight________kg
37.
38. Shaft Data
39. Shaft extension (load end) _______________(in/cm)
40.
41. Space Heaters: (Operating Conditions)
42. Wattage_______kW Max. Surface Temp.______°C
BI/JO No. _______________________________
PO/RFQ No.________________L/I No.________
Data Sheet Page 2 of 2 By: ______________
Date _________________ Revision __________

© Saudi Arabian Oil Company, 2021 Page 13 of 14

Saudi Aramco: Company General Use


Document Responsibility: Motors and Generators Standards Committee 17-SAMSS-503
Issue Date: 18 November 2021 Severe-Duty, Totally Enclosed,
Next Revision: 18 November 2026 Squirrel Cage Induction Motors to 500 HP

B. Modified IOGP S-703 Data Sheet

Follow SA-2861: IOGP S-703D Data Sheet for Low Voltage Three Phase
Cage Induction Motors. Note that the additional notes are mandatory
requirement.

© Saudi Arabian Oil Company, 2021 Page 14 of 14

Saudi Aramco: Company General Use

You might also like