Professional Documents
Culture Documents
Competency
standard: DRIVING NC II
SECTOR LAND TRANSPORT
Unit of 1. Carry out Minor vehicle maintenance.
competency: 2. Drive Light Vehicle
3. Obey and observe traffic rules and regulations.
4. Implement and Coordinate accident emergency
procedures
Ways in which evidence will be collected:
[tick the column]
Oral Questioning
Demonstration
Observation
Written
The evidence must show that the trainee can…
Perform vehicle maintenance minor
servicing
Perform light vehicle pre-starting and
warm up
Drive light vehicle
Obey and observe traffic rules and
regulation
Practice road courtesy
Implement and coordinate accident-
emergency procedure
Assessors
Name and Date:
Signature
NOTE: *Critical aspects of competency
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
DEMONSTRATION
Candidate name:
Assessor name:
Project-Based Assessment: 1. Carry out Minor vehicle maintenance.
2. Drive Light Vehicle
3. Obey and observe traffic rules and
regulations.
4. Implement and Coordinate accident-
emergency procedures
Qualification: DRIVING NC II
SECTOR LAND TRANSPORT
Date of assessment:
Time of assessment:
Instructions for demonstration
This module covers the knowledge skills and attitudes required to drive a light vehicle
including handling of passengers, systematic and efficient control of all vehicle functions,
monitoring of traffic and road conditions and management of vehicle condition.
Materials and Equiptment:
to show if evidence is
OBSERVATION demonstrated
During the demonstration of skills, did the candidate: Yes No N/A
Pre starting warm up procedures
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
QUESTIONING TOOL
Satisfactory
Questions to probe the candidate’s underpinning knowledge response
Extension/Reflection Questions Yes No
1. Why you should check before starting an engine?
Safety Questions
2. What is the possible cause if you are not using SET BELT?
Contingency Questions
3. Why is set belt necessary?
Infrequent Events
4. What will you do if the tire of your car burst?
Rules and Regulations
5. Why you should follow Occupational Health & Safety Procedures?
The candidate’s underpinning knowledge was: Satisfactory Not Satisfactory
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
TEST QUESTION
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
9. To achieve smooth shift and prevent engine stalling, depress smoothly.
a. Clutch and accelerator pedal
b. Brake pedal
c. Accelerator pedal
d. Clutch pedal
10. Which of the following is the best driving practice when starting an engine of a
vehicle equipped with automatic transmissions?
a. Depress the brake pedal
b. Transmission is in 1st gear and depress clutch pedal
c. Transmission in neutral and depress clutch pedal
d. Depressed gas pedal so with the brake pedal
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
PORTFOLIO EVALUATION Form
For DRIVING NC II Institutional Assessment
Candidate name:
Assessor name:
Project-Based Assessment: 1. Carry out Minor vehicle maintenance.
2. Drive Light Vehicle
3. Obey and observe traffic rules and
regulations.
4. Implement and Coordinate accident
emergency procedures
Qualification: DRIVING NC II
SECTOR LAND TRNSPORT
Date of assessment:
Time of assessment:
Instructions for demonstration
/ Valid / Authentic / Sufficient / Current item no[s]
Notes (N)
Prepared by:
ISIDRO S. LANOY JR February 18, 2022
RATING SHEET for DRIVING NC II Institutional Assessment.
Candidate name:
Assessor name:
Project-Based Assessment: 1. Carry out Minor vehicle maintenance.
2. Drive Light Vehicle
3. Obey and observe traffic rules and
regulations.
4. Implement and Coordinate accident
emergency procedures
Qualification: DRIVING NC II
SECTOR LAND TRANSPORT
Date of assessment:
Time of assessment:
Instructions for demonstration
Allow the Candidates to have enough time to read the Specific Instructions to
Candidates.
Candidates are allotted to accomplish the demonstration for two (2) hours
Materials and Equiptment:
1. EWD 6. Fuel
2. Oil 7. Grease
3. Water 8. Dunce Pin
4. Coolant 9. Hyraulic Jack
5. ATF 10. Vehicle Unit
to show if evidence is
OBSERVATION demonstrated
During the demonstration of skills, did the candidate: Yes No N/A
Perform vehicle maintenance minor
servicing
Prepared by:
ISIDRO S. LANOY JR February 18, 2022