Professional Documents
Culture Documents
www.maccaferri.com
Software Suite for Embankments Design
Client: pag. 1 of 2
Project Information
Title: Description:
Number:
Client:
Designer:
Input
Geometry Reinforcement
Embankment Properties Stress-strain curve
Height of fill [m] 2 Product family ParaLink (BBA Values)
Side slope "n" 2 Design reinforcement strain [%] 5
Unit weight of fill [kN/m³] 18
Friction angle [deg] 35 Partial factors ULS SLS
Surcharge load [kPa] 20 Manufacturing 1.00 1.00
pp_Tp
Extrapolation of test data 1.05 1.05
Soft Soil Properties Installation damage 1.05 1.05
Depth of soft soil [m] 4 Environmental effects 1.05 1.05
Undrained shear strengthof the foundation soil [kPa] 20 Ramifications of failure 1.10 1.00
Increase in undrained shearstrength with depth [kPa/m] 0 Reduction factor for creep 1.38 1.00
MACBARS Soft Soil | MACBARS Studio | Copyright ® Officine Maccaferri S.p.A 2012-2019. All Rights Reserved. | v 1.0.12 | 2019.07.04 | Notice: Maccaferri is not responsible for the drawings and the
calculations transmited, since they should be intended as general design outlines and advice, aiming only to the best use of the produts.
MACBARS Soft Soil | Embankment Design on Soft Soil
www.maccaferri.com
Software Suite for Embankments Design
Client: pag. 2 of 2
Results
Design Calculations Limit States
Reinforcement strength Local stability ULS SLS
Reinforcement type PARALINK 200 H/Ls 0.50 0.50
Ultimate Tensile Strength [kN/m] 201 tan f'cv/fms 0.70 0.70
Minimum Ultimate Tensile Strength [kN/m] 156.90
Lateral sliding ULS SLS
Reinforcement strain
Tensile load in the reinforcement to resist 26.77 20.60
Strain in the reinforcement after 24 hr [%] 5.18 lateral thrust, Tds [kN/m]
Strain in the reinforcement after 1M hr [%] 5.60 Min. reinforcement length to prevent 3.80 2.04
lateral sliding, Le,min [m]
MACBARS Soft Soil | MACBARS Studio | Copyright ® Officine Maccaferri S.p.A 2012-2019. All Rights Reserved. | v 1.0.12 | 2019.07.04 | Notice: Maccaferri is not responsible for the drawings and the
calculations transmited, since they should be intended as general design outlines and advice, aiming only to the best use of the produts.