Professional Documents
Culture Documents
Neglecting
the effect of fillets and of stress concentrations, perform calculations in MS excel or MATLAB
for the principal stresses in the beam to satisfy a design specification that they be equal to or
less than 150 MPa. If the principal stresses are more than the given value, what would you
change in the beam so that satisfy the required stresses
Given Data:-
Sr.NO Total Length Registration # Total Load (P) Inertia (I)
1 35 195 0.00006300 m⁴
2
0.4
3
4
Point A
σy=0 Mpa
τ=0 Mpa
Shear Stress Fluxure Principle Stresses
0.00 Kpa 136190.48 Kpa 129.42 Mpa
4164.64 Kpa 120095.24 Kpa 142.73 Mpa
67275.00 Kpa 136190.48 Kpa 77.76 Mpa
818250.00 Kpa
Since the principle maximum stress is 142.73 Mpa and the limitin
beam is 150 Mpa, therefore the beam will not collapse and is s
am. Neglecting
el or MATLAB
be equal to or
t would you
0.013m
0.210m
Point B Point C
σy=0 Mpa
τ=63.926 Mpa
rinciple Stresses Max Shear Min Shear
0 Mpa 64.71 Mpa -64.71 Mpa
-28.62 Mpa 57.055 Mpa -57.055 Mpa
-77.76 Mpa 77.76 Mpa -77.76 Mpa
σy=0 Mpa
σx=0 Mpa
τ=77.76 Mpa