NOTED AND RESUBMIT NOTES TO CONTRACTOR: (1) Notification to proceed or receipt of information does C - DO NOT PROCEED, CHANGE AS not constitute acceptance nor relieve Contractor of any NOTED AND RESUBMIT liability. Acceptance is accomplished under the terms of the Contract/Purchase Order. (2) Changes or additions to any document must be D - INFORMATION ONLY, RECEIPT reflected in its revision block by an appropriated revision ACKNOWLEDGED indication. (3) If the data being resubmitted by the Employer’s Representative supersedes previously submitted data, Q – QUALITY IS BELOW STANDARDS, indication of the replaced document number must CORRECT AND RESUBMIT appear in or near the revision block or on the Transmittal. Contractor Ref: NSH-MAADEN-WPF-WPS-18-P3 Rev: Date Received: Doc Title: WELDING PROCEDURE SPECIFICATION - NSH-MAADEN-WPF-WPS-18-P3 00 14-Sep-2013 Reviewed by: B – PROCEED, CHANGE AS NOTED ® Employer Document No: AND RESUBMIT Authorization to proceed does not relieve Contractor/Supplier of its MD-402-K023-IK-Q10-00022 responsibility or liability under the Contract and or Purchase Order. By Matthew Cox (Matthew.cox@fluor.com) on Sep 23, 2013 Date: Revision 01 CWP: 9mm max. See 25.94mm See QW- 404.30 QW-404.30 (4.5mm deposit on (12.97mm x 2t) PQR)