FOR INSTALLATION OF CLOSED CELL ELASTOMERIC INSULATION FOR DOMESTIC COLD WATER, HOT WATER AND RAIN WATER PIPING SYSTEM Description of Work: Tag No. : Drawing Ref. No.: Location: System No.: Inspection Request No. : Contract No.: Project No: 625 INSPECTION ATTRIBUTES Item Description Accept Reject NA 1. Insulation materials are approved. 2. Check the required thickness of insulation material. 3. Check adhesive for insulating the joints are approved. 4. Check adhesive is not expired. 5. Self adhesive tape is approved 6. Installed piping is inspected and approved. Water tightness test/ Hydrostatic pressure test of installed 7. piping successful carried out and approved. 8. Shop drawings are approved 9. Piping cleaned prior to installing the insulation materials 10. Pre-glued Insulation Butt jointing done properly. All butt joints sealed properly by self adhesive tape after 11. 36 hours of pre-glued Insulation jointing. 12. No air gap between insulation materials and adhesive tape 13. No piping section is left without installation of insulation Exposed interior vertical piping protected from floor to 1.8 14. m above Finish Floor as per specification section 15060 clause 3.1 B. 4 15. Identification Tag installed on insulated piping 16. Work carried out in good workmanship 17. Others