You are on page 1of 4
PROTECTED: Du Not Reproduce TOYOTA ENGINEERING STANDARD TSC7306G 4.5.2 Characteristics after Test (1) Thermal.shock rasistane (2) Solder joint fe {SX e-7 ‘Comply wath oa 0 46.1 Types at Test (1Resonanice,point detection test «Performed to determine ths fegonance weer ofa tomponent {@) Function test under vibration” rmed to cra ty cherocie NES Then da ie evade pene een enna tng fw ae gee Rov. 7 serine wna St bel ease eae Epa hy te nd ‘Scat a paper eT eae Paes 2/37 ‘TMAP-EM :02 300426@9722D Ranasee Krianakrai 201 2015/03/11 16:58:02 300426@9722D Rangsee Kriangkrai 2015/03/11 16: PROTECTED Do Not Reproduce TOYOTA ENGINEERING STANDARD TSC7306G 4.6.2 Test Method (1) Test sequence Resonance point detection test > Function test under vibration -> (2) Component installation Install the component on the jig of the vibration tester so that itis-s actual vehialo. (3) Detection of vibration acceleration 2 Vibration acceleration shall be detected at the bracket of ther¢ Gomparent. If however, the instalation jigs highy rig, itis permitted to measure vibration afceleration onthe shaker. 4.6.3 Test Conditions (1) Resonance point detection test Detect the resonance point by increasing and décteesing the tech ata constant rate within the vibration range shown in Table 8, OA f SYS lable 8_Kefijnance Point Detection est Conditions item ONS SS Cutdiion Frequency ranga (Hz) ‘Sweep period (min) Vibration acceleration (m/S*); Excitation direction NS sand ona (19) Perfor the test at effective acceleration values\tor fing} sésonance points. (20) The onenation of compart in vehicle shal 6 used 4 reference (2),Functio test under vibration. \

You might also like