Professional Documents
Culture Documents
Exercise 19
Exercise 19
Exercise 19
1. Start Revit 2019
5. Using Reference Plane command, add the following planes at the edge of face
of each toilet’s wall, and at the middle:
7. Click (EQ) for each dimension; to make all dimensions equally spaced, hence
making sure that the middle ref plane is at exactly the middle of the gents room
8-8
Chapter 8: Plumbing Networks
8. Delete the three dimensions, when the warning message comes up, click OK.
11. In the Gents Room, add two M_Urinal – Wall Hung 25mm Flush Valve
12. Start Plumbing Fixtures, click Load Family button, go to Plumbing / MEP /
Fixtures / Lavatories / M_Lavatory - Wall Mounted.rfa
13. Insert three of these in the Gents Room, and three in Ladies Room
14. Start Mechanical Equipment, click Load Family button, go to Plumbing / MEP /
Equipment / Water Heaters / M_Water Heater.rfa
15. Insert one 152 L in the Cafeteria at the lower right corner, and set Offset =
1000mm
8-9