Professional Documents
Culture Documents
STANDARD OPERAT
( a) Clean the Checking area before ( a ) Remove the part fron the bag & @ Connect the HMSL connector to
starting the work check for the scarches & other defects electric connection as shown in picture
like lens brackage.
Marathi translation
©. Take care there should not be no ©.If scraches found reject the part & © Whlie connecting the HMSL there
dust record the rejection in rejection book should not be any loose contact
Marathi translation
® If dust found clean the dust with ® Rejected parts keep in rejection area ®
cloth
Marathi translation
Check the following points before start the work. Related documents
1)Table & resting fixture should be clean. 1)Process work instruction sheet.
2) Check the availability of red bin (rejection)and yellow bin(hold) 2)Control plan
DOCUMENT NO:
ISSUE DATE:
REV. NO:-
REV DATE: -
`
4 5
@ Connect the HMSL connector to @ Check all the lamps of HMSL are @ If found the HMSL OK, then mark
ectric connection as shown in picture in glowing condtion the part with black sticker & Keep it in
Ok Parts
© Whlie connecting the HMSL there © If found one of the lamp is not ©
hould not be any loose contact glowing then reject the HMSL
© Quality Points
® Risk
( a) Clean the Checking area before ( a ) Remove the part fron the bag & @ Connect the HMSL connector to
starting the work check for the scarches & other defects electric connection as shown in picture
like lens brackage.
©. Take care there should not be no ©.If scraches found reject the part & © Whlie connecting the HMSL there
dust record the rejection in rejection book should not be any loose contact
® If dust found clean the dust with ® Rejected parts keep in rejection area ®
cloth
Check the following points before start the work. Related documents
1)Table & resting fixture should be clean. 1)Process work instruction sheet.
2) Check the availability of red bin (rejection)and yellow bin(hold) 2)Control plan
Prepared By :
STANDARD OPERATING PROCEDURE
DOCUMENT NO:
1 REV. NO:-
REV DATE: -
`
Connect the Electric connection 4 Check the lamp 5 Marking for OK lamp
@ Connect the HMSL connector to @ Check all the lamps of HMSL are @ If found the HMSL OK, then mark
ectric connection as shown in picture in glowing condtion the part with black sticker & Keep it in
Ok Parts
© Whlie connecting the HMSL there © If found one of the lamp is not ©
hould not be any loose contact glowing then reject the HMSL
© Check Points
® Risk
Approved By: