Professional Documents
Culture Documents
Comments Exceptions
Links are to Current Saudi Aramco Standards
Page 1 of 2
Saudi Aramco 2616-ENG (11/2010)
THIS DRAWING AND THE INFORMATION CONTAINED HEREIN ARE THE SOLE PROPERTY OF SAUDI ARAMCO. NO REPRODUCTION IN FULL OR IN PART SHALL BE OBTAINED FROM THIS DOCUMENT WITHOUT THE WRITTEN CONSENT OF ITS OWNER.
where
tn= 0.389 inch
P = design pressure, psig = 2000 PSI
D = nominal outside diameter of pipe, in. = 6.625 inch
Tn= 0.5 inch
Entry 12 S = specified minimum yield strength, ps = 60000 PSI
where F = design factor = 0.72
07/31/2016
DATE
10-01277-6497
00
MAOP = 2014 PSI MAOP for ASME900# valve @230 oF = 2014 PSI
Limited By ANSI 900# Valve MAOP MAOP = lesser value of the following:
(MAOP of pipe, MAOP of flange & MAOP of valve)
Pipeline MAOP = Minimum of ( 2014,2014,2014)
OPERATIONS/DATE
Pipeline MAOP = 2014 Entry 25 Pipeline MAOP = Minimum of the MAOP's for each line s
07/31/2016
AMR
System MAOP = Minimum of 2014 , 2000 ) System MAOP = Minimum of the following:
REVIEW FOR KEY DRAWINGS
REQUIRED (SAUDI ARAMCO)
Minimum code test pres. 2518 PSI ASME B31.8 Minimum code test pres. 1.25 X Pipeline MAOP
07/31/2016
Flange test pressure = 1.5x2250 = 3375 PSI Flange test pressure = Per ASME B16.5, TABLE II-2-1.7
SAH
Valve test pressure = 1.5x2220 = 3330 PSI Valve test pressure = Per ASME B16.34, TABLE VII-2-2.
2 X 0.9 X S X Tn
Pipe wall test Pressure = 8151 PSI Pipe wall test Pressure = SAES-L-150
D
✘
Line test pressure = 3350 * PSI Line test pressure = The greater value of the following :
1. Minimum test pressure of (pipe wall, flange, valve)
CERTIFIED/DATE
Limited By ANSI 900# Valve Test Pressure 2. Minimum test pressure as per ASME B31.8
07/31/2016
Pipeline test pressure = 3350 Entry 28 lesser value of the test pressure for each line size
Limited By ANSI 900# Valve Test Pressure Entry 30 * rounded off to the next higher 1 bar (25 psi) increment.
Entry # 36 - Safety Valve Set Pressure
ENGG./DATE
07/31/2016
Safety Valve Set Pressure 3518 Entry 36 Safety Valve Set Pressure for Strength Test =
EST
10-01277-6497-017
DRAWING COMPLETION CERTIFICATE NO.
00
THIS REVISION NO.
SIS FOR 6"-P-0104-9CS9P DWG. TYPE PLANT NO. INDEX DRAWING NO. SHT.NO REV.NO.