Professional Documents
Culture Documents
Đề số : CANDT/2018-CC2-EOC-ET
Cấp : 2
ID:
Chữ ký:
Chữ ký:
Điểm thi:
……….………./25 = ……………….%
1. Which is the following products would be the most applicable to a test using an
inside coil / Những sản phẩm nào sau đây sẽ là ứng dụng nhiều nhất đối với cuộn
dây đấu dò dạng nằm bên trong:
a) Sheet / tấm
b) Rod / thanh tròn
c) Bolt hole / lỗ đai ốc
d) Coating thickness / độ dày lớp phủ
2. When eddy current testing rod for discontinuities, which of the following
conditions could produce extraneous indications? / khi kiểm tra bất liên lục trong
các vật kiểm dạng thanh tròn, những điều kiện nào sau đây có thể tạo ra các chỉ thị
bất thường
a) Improper adjustment of the hole down rollers used to center the rod in the coil /
việc điều chỉnh không thích hợp các con lăn dẫn động dùng định tâm thanh kiểm
trong cuộn dây
b) Rod is feed through the coil at varying speeds / thanh được kéo xuyên qua cuộn
dây với các vận tốc thay đổi
c) Changes in diamension/ những thay đổi về kích thước
d) All of the above / tất cả các câu trên
Trang 1 / 6
3. One method of reducing nonrelevant indications when testing ferromagnetic
materials is to: / một phương pháp giảm những chỉ thị không liên quan khi kiểm
tra vật liệu sắt từ là:
a) Decrease the pressure on the hole-down-roller / giảm áp suất trên con lăn dẫn
động
b) Use a Direct Current saturation coil to magnetically saturate the test specimen/
Dùng một cuộn dây dòng một chiều bảo hòa để bão hòa từ vật kiểm
c) Readjust the gain control / điều chỉnh lại núm điều chỉnh độ lợi
d) Increase the rate of feed through the coil/ tăng vận tốc kéo cuộn dây
7. An alternating current flowing in a conductor will set up / một dòng xoay chiều
trong một vật dẫn sẽ tạo nên:
a) An alternating current field around the conductor / một trường dòng xoay chiều
xung quanh vật dẫn
b) A periodically changing voltage tangent to the conductor / một điện áp thay đổi
theo chu kỳ tiếp tuyến với vật dẫn
c) An alternating magnetic field around the conductor / một từ trường xoay chiều
xung quanh vật dẫn
d) Non of the above / không câu nào kể trên
Trang 2 / 6
8. The characteristics of the alternating magnetic field in the vicinity of the AC coil
are affected by: / Đặc tính của từ trường xoay chiều trong phạm vi lân cận cuộn
dây AC bị ảnh hưởng bởi:
9. When using an encirling coil with both primary and secondary windings, the
exicitation alternating current is applied to:/ Khi dùng một cuộn dây gồm cả cuộn
sơ và thứ cấp, dòng kích thích xoay chiều được áp dụng cho:
10. Which of the following is not a readout system used to present eddy current test
information?/ Cơ cấu nào sau đây không phải là một hệ thống dùng để hiển thị
thông tin về kiểm tra dòng xoáy?
a) Calibrated and uncalibrated meters / các đồng hồ được kiểm định và không kiểm
định
b) Litmus paper / giấy quỳ
c) Cathod ray tube / ống phóng tia âm cực
d) Strip-chart recorder / bộ ghi biểu đồ ký
11. Which of the following statements best describles the selection of eddy current
test fequency?/ câu nào dưới đây mô tả chính xác nhất việc chọn tần số kiểm tra
dòng xoáy?
a) The frequency must equal the f/fc ratio to give accure test / tần số phải chọn
tương đương tỷ số f/fc để có kiểm tra chính xác
b) The frequency must be within ± 3% of the f/fc ratio to give acurate test/ tần số
phải chọn trong khoảng ± 3% tỷ số f/fc để có kiểm tra chính xác
c) There is a range of suitable frequencies centered around the optimum frequency /
có một dãi tần số thích hợp tập trung xung quanh tần số tối ưu
d) The frequency should be within ± 25% of the characteristic frequency / tần số
phải chọn trong khoảng ± 25% của tần số đặc tính
12. Which of the following is not a method that may be used to improve the signal-
to-noise/ Phương pháp nào sau đây không phải là một phương pháp có thể dùng để
cải thiện tỷ số tín hiệu trên nhiễu
a) Change to a test frequency that will decrease the noise / chuyển sang một tần số
kiểm tra mà tần số này sẽ làm giảm nhiễu
b) Increase the amplification of the test instrument / tăng khuyếch đại của thiết bi
kiểm tra
c) Improve the fill factor / cải thiện hệ số lấp đầy
Trang 3 / 6
d) Add filter circuits to the instrument / thêm mạch lọc vào thiết bị
13. When conducting an eddy current test on tubing, the magnitude of the
indication caused by a discontimuity is dependent on:/ Khi kiểm tra dòng xoáy trên
ống kiểm, biên độ chỉ thị gây bởi một bất liên tục phụ thuộc vào?
14. A coil’s magnetic field may be viewed as a distribution of lines of flux around
the coil. The number of lines in a unit area is defined as:/ Từ trường của cuộn dây
có thể quan sát như một sự phân bố đường sức từ xung quanh cuộn dây. Số lượng
đường sức trên một đơn vị diện tích được định nghĩa là:
15. Which of the following discontinuities would be easiest to detect with an eddy
current test? / Loại bất liên tục nào sau đây dễ phát hiện nhất bằng kiểm tra dòng
xoáy?
a) A crack that lies parallel to the direction of the eddy current flow / một vết nứt
nằm song song với hướng của dòng xoáy
b) A discontinuity located in the center of a 51 mm (2 in.) thick diameter rod / Một
bất liên tục tại tâm của thanh đặc có đường kính 51 mm (2 in.)
c) A radial crack that extends to the outer surface of a rod / Một vết nứt có hướng từ
tâm mở ra bên ngoài bề mặt của thanh
d) A subsurface radial crack located at a depth of 13 mm (0.5 in.) in a 51 mm (2 in.)
diameter rod / một vết nứt có từ hướng tâm hướng ra tại gần bề mặt tại độ sâu 13
mm (0.5 in.) trong một thanh đường kính 51 mm (2 in.)
16. Eddy current test techniques can be used to: / Kỹ thuật kiểm tra dòng xoáy có
thể được dùng để
17. Eddy current can not be induced in / dòng xoáy không thể cảm ứng trong:
a) Aluminum /nhôm
b) Latex paint / sơn phủ bằng nhựa
c) Steel / thép
d) Copper /đồng
Trang 4 / 6
18. Which of the characteristics do not apply to magnetic material / những đặc tính
nào sau không áp dụng với vật liệu từ tính?
19. Which of the following is not an eddy current testing method ?/ phương pháp
nào sau đây không phải là một phương pháp kiểm tra dòng xoáy?
20. Eddy currents always travel: / dòng xoáy luôn dịch chuyển
a) Enable a high-pass filter in the eddy current test equipment/ Kích hoạt chức năng
lọc cao qua trong máy kiểm tra dòng xoáy.
b) Enable a low-pass filter in the eddy current test equipment/ Kích hoạt chức năng
thấp qua trong máy kiểm tra dòng xoáy.
c) Increase the bandpass of the amplifier/ Tăng (tần số trung bình) băng thông của
bộ khuếch đại.
d) Use the impedance method of testing / Sử dụng phương pháp kiểm tra tổng trở.
22. Which of following method may not be used to improve the signal-to-noise ratio
of an electro-magnetic testing system? / Phương pháp nào sau đây có thể không sử
dụng để tăng cường tỷ số tín hiệu trên nhiễu của 1 hệ thống kiểm tra điện từ?
Trang 5 / 6
23. In order to decrease the effect on conductivity readings due to variations in test
part thickness/ Để giảm sự ảnh hưởng của giá trị độ dẫn điện do sự thay đổi độ dày
vật kiểm tra:
a) The test frequency should be increased/ nên tăng tần số kiểm tra
b) The test frequency should be decrease/ nên giảm tần số kiểm tra
c) The fill factor should be decrease/ nên giảm hệ số điền đầy
d) There is no practical method for decreasing this effect/ không có phương pháp
thực hành nào để giảm hiệu ứng này.
24. When testing by the eddy current technique, discontinuities will be most easily
detected when the eddy current are/ Khi kiểm tra bằng kỹ thuật dòng xoáy, bất liên
tục dễ ghi nhận nhất khi dòng xoáy là:
25. A term used to describe the effect observed due to a change in the
electromagnetic coupling between a test specimen and a probe coil when the
distance of separation between them is varied is:
Trang 6 / 6