Professional Documents
Culture Documents
MSP300 0078 Conica 39
MSP300 0078 Conica 39
Release components of
oil tank. tension wear or cracks. in lube oil tank. the spherical seat, rotate
back & forth.
2. Check oil temperature 2. Check for oil leaks in 2. Change lubrication oil 2. Check lubrication oil for
acc. to thermometer. crusher, pipeline, in Countershaft. dirt and sludge, change if
cylinder & motor. necessary.
3. Check oil pressure acc. 3. Check mantle and 3. Inspect the oil in the oil
to pressure gauge. concave for tightness. tank for metal chips with a
magnet. Occasional small
metal flakes are normal. A
large quantity of chips may
indicate excessive
pressure on bearing &
bushing surfaces or
possible bearing &
bushing failure.
4. Inspect and clear any 4. Check cone crusher 4. Check mantle and
foreign material under dust discharge gap setting concave for wear.
seal ring that may prevent it set value vs. actual
from freely moving with value.
head.
5. Check power draw on 5. Check and clean oil 5. Check top cell liner and
motor. tank strainer. tightening nut for wear.
6. Check adjustment cap 6. Check counter shaft 6. Check seat liner groove,
screws & cap frame for housing air breather. replace seat liner if groove
tightness. is lower than 4 mm.
7. Check for loose fasteners 7. Grease upper frame 7. Check seat liner fixing
and connections. and top cell threads via screws, if loose, remove &
the lubrication hole on apply locking compound
the upper frame. before putting them back.
8. Check for unusual noise 8. Check tightness of
& changes, indications of tightening nut.
wear or undue strain on
crusher parts.
31