Professional Documents
Culture Documents
7
TI 7 -97 08 21 GT/B
information
en
0 − 0.2 mm
1. Bush 1
2. Wear washer
3. Shim
4. Sleeve
107 144
4 3 2
© Scania CV AB
(744) 1997 1
Mounting description Setting
To mount the bushing you need a service drift Turn the steering knuckle to make sure that it is
which you make according to the attached dra- moving freely.
wing.
Measure the distance between the axle beam
• Remove the bottom cover, the packing and the steering knuckle with the knuckle lif-
shims, the roller bearing and the king pin. ted by a jack. Adjust if necessary with shims.
Distance 0 - 0.2 mm.
• Press the bushing into the steering journal
bore with the service drift. Press to the bot- Grease with chassis grease through grease nipp-
tom of the drift. The bush should end 8 mm le that should face the centre of vehicle.
from the edge of the journal bottom. Slit
pointing towards the hub bearings. See also SI 7-93 11 22.
97
© Scania CV AB
2 TI 7 -97 08 21 GT/B en